Professional Documents
Culture Documents
1 3 Mine Gases Gases in Mine Air II
1 3 Mine Gases Gases in Mine Air II
REFERENCES
Page 1 of 9
1.0 HYDROGEN SULPHIDE (H2S)
H2S is a gas with a smell similar to that of a rotten egg and has a sweetish
taste with a specific gravity of 1.175. It burns with a light blue flame and is
soluble in water. It is also known as Stink Damp. It is combustible and is
explosive over a wide range of its concentration from 4.3 % to 45.5 %. It is
more poisonous than CO and has a TWA value of 10 ppm and an STEL value
of 15 ppm as per the recommendations of the American Conference of
Governmental Industrial Hygienists (ACGIH) and US National Institute of
Occupational Safety and Health (NIOSH). H2S is not very common in mines
and usually occurs in firedamp and gob fires in sulphurous coal. It is formed
naturally by bacterial/chemical decomposition of organic compounds and is
often detected near stagnant pools of water in underground mines. It may
also occur in natural gas and petroleum reserves and migrate through the
strata in a weakly acidic water solution. In metal mines it is produced by the
action of acidic water on iron pyrites which can be represented by the
equation:
Hydrogen sulfide has a very low odor threshold, with its smell being easily
sensed by the human nose at concentrations well below 1 part per million
(ppm) in air. The odor increases as the gas becomes more concentrated, with
the strong rotten egg smell recognizable up to 30 ppm. Above this level, the
gas is reported to have a sickeningly sweet odor up to around 100 ppm.
However, at concentrations above 100 ppm, a person's ability to detect the
gas is affected by rapid temporary paralysis of the Olfactory nerves (the first
Page 2 of 9
pair cranial nerves that conduct impulses from the mucous membranes of the
nose to the olfactory bulb) in the nose, leading to a loss of the sense of
smell. This means that the gas can be present at dangerously high
concentrations, with no perceivable odor. Prolonged exposure to lower
concentrations can also result in similar effects of olfactory fatigue. This
unusual property of hydrogen sulfide makes it extremely dangerous to rely
totally on the sense of smell to detect the presence of the gas. The
physiological effects of H2S poisoning are given in Table 1.
Concentration Effects
of H2S (ppm)
50-100 Slight irritation to eyes and respiratory tract, headache
200 Intensified irritation of nose and throat
500 Serious inflammation of eyes, nasal secretions, coughing,
palpitations, fainting
600 Chest pains due to corrosion of respiratory system, may be
fatal
700 Depression, coma, probable death
1000 Paralysis of respiratory system, very rapid death
A person who recovers from H2S poisoning may have conjunctivitis and
bronchitis for a long period after recovery.
Page 3 of 9
paper soaked in lead acetate solution to an atmosphere containing H2S gas.
The filter paper turns brown and then black if the concentration of the gas is
sufficiently high. The M.S.A. H2S detector is an accurate instrument for
detecting H2S. It consists of a glass tube filled with white granules of
activated aluminum oxide coated with silver cyanide. When gas containing
H2S is drawn through the tube, the gas combines with silver cyanide forming
black silver sulphide which turns the granules black. The percentage is
calculated with the help of a scale placed along the side of the tube which
measures the length up to which the change of color has taken place.
Nitrous fumes are rarely found in mines and mainly consist of nitric oxide,
nitrogen dioxide and nitrogen tetra-oxide. The original product is nitric oxide
(NO) which quickly combines with oxygen to form nitrogen dioxide (NO2),
which has a pungent smell like that of fuming nitric acid. As NO2 cools down
it is slowly converted to nitrogen tetra-oxide (N2O4), which is a colorless gas.
The specific gravity of NO is 1.036, specific gravity of NO2 is 1.519 and
specific gravity of N2O4 is 1.588. The nitrous fumes are highly soluble in
water. These fumes are very poisonous and TWA value for NO is 25 ppm, for
NO2 is 50 ppm and for N2O4 is 3 ppm as per the recommendations of the
American Conference of Governmental Industrial Hygienists (ACGIH) and US
National Institute of Occupational Safety and Health (NIOSH). The nitrous
fumes are mainly produced by explosives containing nitroglycerine and in
exhaust fumes of diesel locomotives. They are also found in shafts and
tunnels where heavy shot firing takes place in a confined place.
Page 4 of 9
2.2 Physiological Effects
The brown fumes of NO2 get dissolved in water and produce nitrous acid
(HNO2) and nitric acid (HNO3). These acids cause irritation and corrosive
effect on eyes and respiratory system.
Various physiological effects of these fumes at different concentrations are
given in Table 2.
Concentration Effects
of NO2 (ppm)
60 Minor throat irritation
100 Coughing may commence
150 Severe discomfort, may cause pneumonia later
200 Conditions are likely to be fatal to human beings
The common test for nitrous fumes is to soak a filter paper with starch and
potassium iodide solution and expose it to the air containing nitrous fumes.
The paper turns blue by the liberation of iodine. Tube type detectors are also
available which indicate the percentage of nitrous fumes by the length of
change in color in the tube. For example tubes manufactured by Drager use
diphenyl benzidine as the reactant.
Page 5 of 9
3.0 SULPHUR DIOXIDE (SO2):
This is a colorless gas with a very suffocating odor and a specific gravity of
2.264. It is highly soluble in water. The TWA value for this gas is 2 ppm and
STEL value is 5 ppm as per the recommendations of the American
Conference of Governmental Industrial Hygienists (ACGIH) and US National
Institute of Occupational Safety and Health (NIOSH). It is found in smaller
quantities in afterdamp (Afterdamp is a mechanical mixture of gases found in
a mine after an explosion. Afterdamp contains nitrogen and carbon dioxide as
the chief constituents along with carbon monoxide, methane, water vapour,
hydrogen, oxygen and small quantities of H2S and SO2. A typical composition
of afterdamp may be as follows: CO-1.5%, CO2-8%, O2-5%, CH4- 0.3%, H2-
0.2%, N2-85%) in some coal mines, but occurs abundantly in sulphide ore
mines with fires. Blasting in rich sulphide ores also produces large quantities
of SO2 and H2S. It is also released from the exhaust of internal combustion
engines.
Concentration Effects
of SO2 (ppm)
20 Irritation of eyes and respiratory system
50 Severe burning sensation in eyes, nose and throats
400 Immediately dangerous to life
Page 6 of 9
3.3 Detection of SO2
4.0 HYDROGEN
Page 7 of 9
Fig 1.Expolsibility diagram for hydrogen (after Coward and Jones,
1952)
REFERENCES
Bolz, R. E. and Tuve, G. L., eds., Handbook of Tables for Applied Engineering
Science, 2nd ed. CRC Press, Cleveland
Page 8 of 9
Hartman, H. L., Mutmansky, J. M. & Wang, Y. J. (1982); “Mine Ventilation
and Air Conditioning”; John Wiley & Sons, New York.
Page 9 of 9