Professional Documents
Culture Documents
Bearing Plate Design
Bearing Plate Design
Bearing plate of 395mm x 395mm size is checked for stresses due to eccentricity of 6.5mm
under a prestressing force of 561.6 MT from 27 MTAI 15 anchorage system.
Finite element analysis facilitates the accurate analysis of behavior of the plate under
combined bending and shear stresses.
The stress transfer in the eccentric region occurs through shear (critical criterion).
(Annex. B of IS 4623: 2000 gives allowable stress limit of 0.3 Yp for plates used in trunnion
thrust blocks that are subjected to shear. The same limit is used here for safety)
Finite Element Analysis of the bearing plate system is carried out in ANSYS.
Maximum shear stress in the zone of eccentricity = 99.623 MPa (yellow range in the legend)
Hence, additional bearing plate of size 60mm or above transfers the prestressing force
with sufficient safety.
Bearing plate of 60mm thickness maybe also used for transfer of loads in 19 MTAI 15
system.