Professional Documents
Culture Documents
Site Cond PDF
Site Cond PDF
PROJECT N° 04463500
Nº 4635-5-SPC-001
GENERAL SITE CONDITIONS
SPECIFICATION
Prepared by:
FLUOR DANIEL
APPROVED BY:
INDEX
1.0 GENERAL............................................................................................................. 3
1.1. SCOPE OF SPECIFICATION ........................................................................ 3
1.0 GENERAL
This specification defines the site location, site climatic data, site access, site
conditions and accommodations.
2.0 LOCATION
The Yanacocha Mine Site is located in the north east part of Peru, approximately 25
kilometers north of Cajamarca.
Maximum highway traffic load length is 29.9 m. Maximum load size and
weight are limited by the following two bridges that are located on the
highway to Salaverry.
The ports utilized by Minera Yanacocha for ocean shipments are primarily
Salaverry, but also Callao and Paita.
2.3 ACCOMMODATION
Electrical, lighting and thunder storms occur in the hills surrounding the mine site.
Adequate protection of personnel and equipment is required.
Seismic Data
Peruvian Zone 3
The plant design shall be in accordance with NFPA standards, applicable local codes
and regulations, and Owner’s broker insurance requirements
6.0 RESTRICTIONS
6.1 SAFETY
Safety is a paramount requirement for all personnel on site. No person may enter the
site without approved attire and training.
6.2 SECURITY
6.3 ENVIRONMENTAL
Power will be distributed throughout the plant site at 4160 and 480 volts, 3 phase, 3 wire, and
220 volt single phase.
Fresh water for plant operation is received from deep wells and distributed throughout the
plantsite.
Plant service air and instrument air source pressure is 760 kPa (110 psig).