Graphics, problem statements, tables, graphs etc. to supplement board
activity (The slides, being aids for discussion, are by no means replacement of the text book) Problem 11-1 A certain application requires a ball bearing with the inner ring rotating, with a design life of 25 kh at a speed of 350 rev/min. The radial load is 2.5 kN and an application factor of 1.2 is appropriate. The reliability goal is 0.90. Find the multiple of rating life required, xD , and the catalog rating C10 with which to enter a bearing table. Choose a 02-series deep- groove ball bearing from Table 11–2 and estimate the reliability in use. Problem 11-1 A certain application requires a ball bearing with the inner ring rotating, with a design life of 25 kh at a speed of 350 rev/min. The radial load is 2.5 kN and an application factor of 1.2 is appropriate. The reliability goal is 0.90. Find the multiple of rating life required, xD , and the catalog rating C10 with which to enter a bearing table. Choose a 02-series deep- groove ball bearing from Table 11–2 and estimate the reliability in use. Problem 11-3 An angular-contact, inner ring rotating, 03-series cylindrical roller bearing is required for an application in which the life requirement is 40 kh at 520 rev/min. The design radial load is 7342 N. The application factor is 1.4. The reliability goal is 0.90. Find the multiple of rating life xD required and the catalog rating C10 with which to enter Table 11–3. Choose a bearing and estimate the existing reliability in service. Problem 11-3 An angular-contact, inner ring rotating, 03-series cylindrical roller bearing is required for an application in which the life requirement is 40 kh at 520 rev/min. The design radial load is 7342 N. The application factor is 1.4. The reliability goal is 0.90. Find the multiple of rating life xD required and the catalog rating C10 with which to enter Table 11–3. Choose a bearing and estimate the existing reliability in service. Problem 11-4 A pair od bearings support a shaft. If the individual reliabilities of the two bearings are 0.945 and 0.917, what is the reliability of the two bearings (probability that either or both will not fail)? What does this mean in setting reliability goals for each of the bearings of the pair on the shaft?