Professional Documents
Culture Documents
RG-AP130-W Access Point Quick Installation Guide
RG-AP130-W Access Point Quick Installation Guide
Ruijie Networks©2017
Ruijie Networks reserves all copyrights of this document. Any reproduction, excerption, backup, modification,
transmission, translation or commercial use of this document or any portion of this document, in any form or by any means,
without the prior written consent of Ruijie Networks is prohibited.
Exemption Statement
This document is provided “as is”. The contents of this document are subject to change without any notice. Please obtain
the latest information through the Ruijie Networks website. Ruijie Networks endeavors to ensure content accuracy and will
not shoulder any responsibility for losses and damages caused due to content omissions, inaccuracies or errors.
Preface
Thank you for using our products. This manual will guide you through the installation of the device.
This manual describes the functional and physical features and provides the device installation steps, hardware
troubleshooting, module technical specifications, and specifications and usage guidelines for cables and connectors.
Audience
It is intended for the users who have some experience in installing and maintaining network hardware. At the same time, it
is assumed that the users are already familiar with the related terms and concepts.
Related Documents
Documents Description
Describes network protocols and related mechanisms that supported by the
Configuration Guide
product, with configuration examples.
Describes the related configuration commands, including command modes,
Command Reference
parameter descriptions, usage guides, and related examples.
Symbol Conventions
Means reader be careful. In this situation, you might do something that could result in equipment damage or loss of
data.
1.1 Packing List
The key hole and locking bar hole are used with security accessories.
The access point can be powered either with a DC power adapter or through Power over Ethernet (PoE).
When powering the device through PoE, you need to connect one end of an Ethernet cable to the PoE/uplink port
and the other end to a PoE-capable switch or any power sourcing equipment.
When powering the device through DC power adapter, you need to connect one end of an Ethernet cable to the
PoE/uplink port and the other end to a switch.
The pass through ports (RJ45) on the rear panel and the side panel are directly connected.
The LED indicator is inside of top plate cover, and works after you power on the device.
You can also use the quiet-mode and schedule commands on the AP or AC device to configure the quiet time range.
Table 1-2 LED Indicators on RG-AP130-W
Step 1: Remove the 86-type panel from the wall with a screwdriver. (If needed)
Step 2: Connect the Ethernet cable to the UpLNK port on the rear of the access point, and connect the telephone cords to
the pass through port if needed.
Step 3: Align the screw holes on the panel with the screw holes in the wall, use screws to fasten the access point.
The access point has 4 different color plate cover options (white, black, silver and gold. White as default delivery).
In the Fit mode, the IP address of the LAN port and the UpLNK port are 192.168.110.1/24.
In the Fat mode, the IP address of the LAN port is 192.168.111.1/24, and the IP address of the UpLNK port is
192.168.110.1/24.
When the AP is switched to the Fat mode, the Quick Settings page is displayed
Configure the Internet connection type and related parameters, then click Next.
Configure the WiFi parameters, and click Finish to finish the configuration.