Professional Documents
Culture Documents
Work Sheet 2 Gas Detector
Work Sheet 2 Gas Detector
Implement Gas Alarm Circuit in Fire Alarm Trainer Board with the following Specification.
To perform experiment to operate Gas (LPG) Detector when used as gas leak detector.
Procedure:
(i) Make the wiring circuit as per the wiring sequence given above and switch ON the power supply.
(ii) Wait 1 to 2 minutes for warm up period. Gas and Heat LED’s flash rapidly and simultaneously
during warm up period. Once it is over, the detector shall enter into sense or normal mode,
During this mode Gas & Heat LEDs flash alternately.
(iii) Light up the Gas/Cigarette lighter.
(iv) Blow at the flame to extinguish it.
(v) Now LPG Gas will still continue leaking out of it’s nozzle which if held near the Gas detector will
trigger it.
(vi) The Gas detector will detect the gas leak and will ON the relay turning ‘NO’ to ‘NC’ and ‘NC’ to
‘NO’ contact we use ‘NO contact to drive siren and siren will start making a sound.
(vii) Remove the lighter from detector and Off the lighter.
Block Diagram:
Result: