Professional Documents
Culture Documents
WM-10 control dampers are a new series of products from the 1 Telaio
FRAME
WM series. The WM-10 series of control dampers are suitable
for the application on square and rectangular ducts. The
control of these dampers can be manual, electric or 2 BLADE
Aletta
pneumatic, according to the needs of the ventilation system.
The installation of these components allows the control of the
air flow rate variation (VAV) or the pressure variation control
on several kinds of plants. Specifically: 3 HOLDING JOINT
Incastro a tenuta
a) HVAC plants regulation
b) modulated calibration 4 Ingranaggio
INTERNAL interno
MECHANISM
Q Regulation-vers_16_00.xls Q-9
CONTROL DAMPERS
PITCH 100 mm WM-10
SERIES
TECHNICAL DATA
NSTALLATION PROCEDURE
CHARACTERISTICS : Mounting
By screws through damper flange and duct flange or by self-
Damper threading screws through damper flange and air-treatment unit
Mobile closing system mounted into an air duct, designed to panel.
control and close air flow.
MOUNTING SYSTEM :
Frame, materials and construction method
The frame is manufactured in extruded aluminium and Damper mounted inside (figure n°2) or at the beginning or at
designed to withstand the lateral stress from to air pressure, the end of the air duct (figure n°3 and 4) fixed by the frame
and built with lateral frame to protect the drive gears. flange to the duct flange. The control damper can be mounted
on the floor or ceiling (figure n°5).
Flange
Manufactured with 30 mm height.
Transversal reinforcement
Present on all dampers with B dimension wider than 1300 mm.
Finishing
Extruded aluminium.
Q Regulation-vers_16_00.xls Q-10
CONTROL DAMPERS
PITCH 100 mm WM-10
SERIES
AIR FLOW RATE - PRESSURE DROP
BLADES REGULATION - DAMPER SECTION
a) Control damper positioned as figure No. 2 a) Control damper positioned as figure No.3
b) Air Flow rate = 2000 m3/h b) Air flow rate = 2000 m3/h
Q Regulation-vers_16_00.xls Q-11
CONTROL DAMPERS
PITCH 100 mm WM-10
SERIES
ACOUSTIC LEVEL
MANUAL CONTROL SYSTEM
ELECTRIC CONTROL SYSTEM
CALCULATION EXAMPLE:
a) values as shown in figure No.1
b) Calculate the result between velocity V(m/s)
x pressure drop rp (Pa) with result 5 x 53 = 265
Figure no. 7
Mechanism, manual control: The basic kit (figure n° 7) includes a handle for the movement and locking, a transmission lever
for the strength of the transmission shaft axle and a numbered modular plate inserted in the internal mechanism, inside the
frame.
Figure no. 8
Mechanism, servo control: The complete kit (figure no. 8) guarantees the functionality of the mechanism via means of an
electrical signal. It includes the transmission axle and adjustable plate fixed to the frame. This plate is drilled in order to fix
standard actuators available on the market.
Q Regulation-vers_16_00.xls Q-12
CONTROL DAMPERS
PITCH 100 mm WM-10
SERIES
HOW TO ORDER
WM Control damper
10 pitch 100 mm
Base
Haight
WM 10 C 800 611
800 811
900 911
1000 1011
1100 1211
1200 1411 B
1300 1611
1400 1811
1500 2011
1600
1700
1800
1900
2000
Q Regulation-vers_16_00.xls Q-13
CONTROL DAMPERS
PITCH 100 mm WM-10
SERIES
OPTIONALS
Q Regulation-vers_16_00.xls Q-14