Professional Documents
Culture Documents
Biomedical Instrumentation: Transducers and Sensors
Biomedical Instrumentation: Transducers and Sensors
Biomedical Instrumentation
Transducers and sensors
November 2015
Biomedical transducers
A transducer is a device that converts a quantity from the measured object into an
electrical signal.
Biomedical transducers are transducers with specific uses in biomedical applications:
physiological measurement,
patient monitoring,
health care.
Measurement quantities: physical and chemical quantities that reflect the
physiological functions in a living body.
Examples:
blood composition - determined from a sample extracted from the body
real-time and continuous measurements - transducer is attached to the body
2
Electrodes
• Bioelectrical potentials - recall:
bioelectrical potentials occur at the cell
membrane due to difference in
ions concentration (mostly Na +, K + and Cl-) in
intracellular fluid and in the extracellullar space
3
Electrodes
• Bioelectrical resting potentials:
– resting potential inside the cell is negative
comparing to the environment
– resting potential of nerve and muscle cells is
typically -70mV to -85mV
4
Electrodes
• Action potentials:
when the cell membrane is stimulated, there is
a sudden change in membrane conductance, first
for sodium ions (cell depolarization), and
then to potassium ions (repolarization)
• Negative potential inside the cell
reduces, such that short-term potential may become
positive
• Such a potential difference is called the action
potential
5
Electrodes
• How to access the cell and measure
bioelectrical potentials?
– individual cells
• thickness of the semi-permeable membrane approx.
10nm
• measurement of in vivo or in vitro
– groups of cells - tissue or organ
• access to tissue or organ - a non-invasive (bloodless) or
invasive measurements
• mutual influence of different tissues /organs
(potentials, impedance)
6
Electrodes
Electrode is an interface
• to connect the measurement devices and
measure bioelectrical potentials, electrode is
used as an interface, however..
The electrode is also a transducer
• exchange charge carriers :
– in electrical circuits, electrons are charge carriers
– in the body, ions are charge carriers
• connects to the surface of the body (skin, mucous
membranes) or on/in the organ inside the body
7
Electrodes
• Most of bioelectric potentials strive to measure
noninvasively, e.g. from the surface of the body, by
placing electrodes on the skin
8
Electrodes
• Using a model of the interface for better understanding
of the interface electrode -tissue
• Passive electrical characteristics of the skin - electrode
interface strive to express by ideal electric components
with intent parameters
– Resistance
– Capacity
9
Equivalent circuit of the skin-
electrode
Electrode
Skin
Biological
Virtual electrode issue
10
Equivalent circuit of the skin-
R
d electrode
P
A
μ - charge mobility
1
q - charge
qn
CP
A n - number of electrons in volume unit
d
12
Equivalent circuit of the skin-
electrode
13
Nonlinearity of the electrode
interface
14
Electrodes
Electrode-electrolyte interface
The current crosses it from left to right. The electrode consists of metallic atoms C.
The electrolyte is an aqueous solution containing cations of the electrode metal C + and anions A-.
15
Metal-electrolyte potential
Potential
double-layer
Metal
Electrolyte
Electrolyte
Potential
Charge
Dissociation of water to H+
and OH- ions
17
Metal-electrolyte potential
• If you plunge a metal in a solution of its salt, the
half cell potential E0 M appears, also the voltage
dependent on the concentration of metal ions in
solution:
RT
E0.5 M E0 M 1 ln cM 1
nF
• If there is some other metal also immersed in a
solution of its own ions, its potential will be
RT
E0.5 M E0 M 2 ln cM 2
nF
18
Polarization voltage
• If these two solutions are separated with semi-permeable
membrane to allow passage of ions, and to avoid the
original combination of solutions, the potential difference between
the solutions can be measured according to the formula
RT [cM 1 ]
E E0.5 M 1 E0 M 2 E0 M 1 E0 M 2 ln
nF [cM 2 ]
• Each electrode that comes in contact with the electrolyte will
have the potential of the expression above. This potential
is undesirable in the measurement of biological voltage
because when using high gain dc amplifier, it causes saturation
of the amplifier. To avoid saturation, amplifier with less gain in the
input is used and the next stages of amplification are
separated with condenser.
19
Dry electrodes
• Used to avoid the
appearance of polarization
voltage.
• The problem is in large input
impedance, which makes
them susceptible to
interference.
• Therefore, the electrode
itself incorporates an
amplifier designed to reduce
the high input resistance to
a small value and thus
reduce the impact of
interference.
Dry electrodes with integrated amplifier
20
Microelectrodes
• They are used to measure the biological
potential of the cells
21
Microelectrodes
• cell attached recording:
– pipette touching the
membrane and forming
a high-ohmic junction
(~ 1GOhm)
• whole cell recording:
– by suction through a
pipette the membrane
breaks - solution in the
pipette and inside of the
cells become uniform
22
Microelectrodes
Extracellular recording
23
Microelectrodes
Action potentials recorded extracellularly
24
Subcutaneous electrodes
• They are used, for example, to measure the voltage
on the individual muscle fibers or groups of neurons in
the brain
• Example of electrode
implantation for deep
brain stimulation
26
Subcutaneous electrodes
27
Surface EEG electrodes
• EEG electrodes (passive, active)
• Conductive paste
and gel
28
Surface EEG electrodes
• 10-20 system - standards for placing EEG
electrodes
29
EEG recording
30
Surface ECG electrodes
• Adhesive:
• Suction (pump to
suck air)
31
Surface ECG electrodes
• Electrodes for extremities (hands and feet):
• EKG recodring
32
EMG electrodes
• Surface
• Subcutaneous
33
EMG recording
34
Surface electrodes - more examples
• EOG electrodes:
• Electrodes for
electrostimulation
35
Literature
• John G. Webster: Medical Instrumentation,
Chapter 5, Biopotential Electrodes
• A. Šantić, Biomedicinska elektronika, 3.
poglavlje, Elektrode za mjerenje biopotencijala
i električne smetnje
36