Professional Documents
Culture Documents
SSAS
add-on kit
1
TT-3000E mini-C GMDSS commission
Before use of the TT-3026C mini-C
transceiver on the Inmarsat-C
system it must be registered to the
system, which involves a little paper
work. This is done using the SARF
(Service Activation Registration
Form) supplied with the mini-C.
In addition to the general
information like name, address, etc.
the ISN of the mini-C MES must be
specified. The ISN is located on the
bottom of the mini-C.
When the mini-C MES is registered
at the ISP it is ready to be
used on the Inmarsat-C network.
The ISP has returned a
Mobile Number for the mini-C MES
and prior to operating the
mini-C MES it must be configured
with this Mobile Number.
2
Grounding of the TT-3000E system
The best grounding is made by screwing the chassis directly on to the ships
structure (provided it’s made of metal). If proper grounding can not be made this
way, then connect the pre-mounted grounding wire to the ships structure. Find an
appropriate location as close as possible to the TT-3616C and shorten the
grounding wire accordingly. Terminate the grounding wire with the yellow ring
terminal found in the accessory kit.
3
TT-3000E mini-C GMDSS Installation
4
TT-3000E mini-C GMDSS Installation
CONNECTING TT-3042C TO TT-3616C.
Alarm panels can be connected to terminal
block J901, J902 and J903. The labelling of the
individual terminals corresponds to the labelling
in TT-3042C. To connect the TT-3042C Remote
Alarm / Distress Box, use up to 100 meter of
shielded cable with 8 wires and a wire cross
section of at least 0.25mm2.
Pin 2 (GND)----------------------------------GND
5
TT-3000E SSAS option Installation
The test button and the alert
buttons must be connected
to the TT-3616C
Interconnection Box. The
test button must be
connected to J1001 and the
two alert buttons must be
connected to J1002 and
J1004 respectively.
Match the wire colour code
with the label on the PCB.
6
TT-3000E SSAS option Installation
SSAS
add-on kit
TT-3000E Troubleshooting
With the command ru –l you will get the status of all connected
devices and show their status.
7
TT-3000E mini-C GMDSS Installation
3616C OK LED:
For normal operation the “3616C OK” LED should be steady on when the system is powered.
A flashing “3616C OK” LED indicates a software update in progress or a missing application.
SSAS OK LED:
This LED is controlled by software and can only be trusted provided the “3616C OK” LED is steadily lit.
If the SSAS option is not installed, the “SSAS OK” LED will be flashing. If the SSAS option is correctly
installed, the LED will be steadily lit.
GMDSS OK LED:
This LED is controlled by software and can only be trusted provided the “3616C OK” LED is steadily lit.
When one or more distress alarm panels are installed, the “GMDSS OK” LED should be steadily lit. In
case the “GMDSS OK” LED is flashing, then:
1) Check that the alarm panels are correctly wired.
2) Check that the +9VDC is not overloaded (shorted) by measuring more than 8V between +9V DC
and GND on each of the connectors J901, J902 & J903. If so, remove the overload. Each of the
connectors J901,
J902 & J903 are equipped with an self reset able fuse, thus after removal of the overload the voltage
should get back to normal.