Professional Documents
Culture Documents
Division Structure
1 Introduction 2
2 Design Criteria 3 to 6
3 Structural Modelling 7 to 8
4 Structural Analysis 9 to 11
5 Graphs 12
6 Members Results 13 to 18
7 Connection Details 19 to 20
Calculation cover sheet
No. of Sheets 1
*If an Excel spreadsheet or other computer file has been checked and has not been attached, enter the name, date and full file
path or PiMS location of the file that was checked. (PiMS nickname or shortlink from Properties – General could also be useful.)
a) Basic Design Information or Source and Reference:
Approved by
Project Manager Signature Date
Distribution
Original to project file
Design Information
Project No.
Made by Checked by
Client Engineer
Responsible
Geometric
Design
Subsoil Conditions
Foundation Type
1. NTRODUCTION
This document reflects of design calculations of Warren truss of steel structure over the
container.
The structure is a majorly a steel Structure with beams, posts & columns. The design has
been carried out according to New Zealand standards.
STAAD Pro software are was used for analysis of warren truss and Idea Statica V9.0 Use
for Steel CONNECTION Design its Member forces, Member stresses, Shear Forces,
Bending Moments and Drift checks were performed.
1.1 Geometry
L = 30 m
B = 25 m
H = 10 m
All Beams (Primary) = UB200 X 29.8
Truss Columns, Secondary Roof Beams & Cross Bracing = C591 X 246 X 20 (PFC180)
Main Columns = UC250 X 89.5
2. DESIGN CRITERIA
2.1 Loads
Following Loads have been Considered for design of Warren Roof Truss Design
Dead Load
Wind Load
Project: WARREN TRUSS DESIGN
Deck Dimensions
Project: WARREN TRUSS DESIGN
3. STRUCTURAL MODELLING
5. Graphs
Project: WARREN TRUSS DESIGN
6. Members Results
6.1 UB 200 X 29.8
Project: WARREN TRUSS DESIGN
6.2 Truss Columns, Secondary Roof Beams & Cross Bracing = C591 X 246 X
20 (PFC180)
Project: WARREN TRUSS DESIGN
7. Connection Details