You are on page 1of 13

This series NVR is a high performance network video recorder, combined

with H.264lH.265 video compression, high-capacity hard disk storage, TCP / lP


transmission, embedded Linux operating system and a variety of other advanced
technologies in the electronic information industry all those ensure that a high-quality,
low bit rate video storage characteristics, and good system stability.

tr--------r P---------r
lConnect I lConnect the NVR and IPC %""""";;---l q------l
I oowerttPC and | | uonnect
monitorl .orr"
I
antenna (Note: some NVR
do not need extra I i'rvnr
' I

I lthe router
Itne ltn" I I
2.1. Antenna Location Step 1: Unscrew the HDD casing from back of NVR.
Step 2: Screw the hard disk tightly to the casing.
Step 3: Find the HDD power cord and data cord in the NVR, and plug
them into the corresponding ports on the hard disk.

MrcreWM
Step 4: Put the HDD casing in the NVR and screw it tightly.

,,_
:C_-/ (',\
@ t&l
(',D)

\_--' This ;nstallation instruction is just for reference. Available time of HDD is based on
il
access channels and actual streams.lf you have any further questions, please contact

Correct method
%
Correct method
our technical support.
Test passed the full range oJ Western Digital, Seagate Sata HDD, recommend the use
of AV-GP series Sata HDD.
lrote.' Please use the recommended HDD that is compatible with the NVR.
The signal coverage of Antenna is simillar to a round circle.Antenna located in center
of the round circle,signal of surrouding is much stronger,but much weaker if antenna
endpoints back off direction. And in order to guarantee the video quality, lpc antenna
should try to keep in parallel or tangent wich NVR antenna.

4.1 Power on
2.2. Panel Description lnstall the NVR correctly (as above) and then connect the power. The NVR LED should
Antena intedace HD-OUT USB interface Antena interface light up and the NVR will boot automatically.
lf your hard drive is not properly connected, the following message will appear on your
screen.

Y@ o o o o
@

ll the NvR you purchased without a hard disk, prease reler to the roflowing operation method,
ifthe NVR has installed the hard disk, ptease skip.
Before you start: 4.2 Login
Disconnect the power from the NVR before installing a hard disk drive (HDD). Log in to the system by inputting your user name and password(Default user name is
Tools Required: Screwdriver. "admin" and the default password "null " means you needn't input the password, Just
Steps (for example): keep the password box blank, you can click"OK'to login directly).
4.3 Power Off(Shutdown)
Right-click the mouse button and select fExrt System]-lshutdown].

Ivote.' lf yo! entdr the wrong password 5 times in the Login dialog box, the current user
account will be locked for 10 minutes.
[Chang-e Password]: Enterlsystem Setupr-Isystem Adminl-tused-liet password] lJote,' Shut down the NVR when you wanl to change or attempt to reconnect the hard
to modify the password. disk drive.

4.4 Restart
Right-click the mouse button and select lExit Systeml+Rebootl.

Note,' Please contact the seller if you forget the password.

,Vole,' Reboot after an outage or forceful shutdown, NVR will save the record before
outage and return to the normal operation mode.
4.5 Setup Wizard 4.5.3 Fast Network
Hight-click the mouse button and select [Selup Wizard].
4.5.1 Choose Phone Client

lNetwork Selup].' Two ways, Auto Configuration and Manual Configuration.


IQR codel: From left to right: Android App address, iphone App address, P2P [Cloud(P2P)]: The code is used to add the device to the P2P account.
access address. [Network DiagnoseJ.' Diagnose whether the network is normal.
[Enable Boot Wizard]: Tick and check to enable boot wizard after reboot. [Network Status]i lndicate whether the network is normal.
[Next .' Click to the wizard configuration.
[Cancel]: Click to exit the wizard. 4.5.4 HDD Setup

4.5.2 Language and Region

lFormat]: Format the disk.


ITime Zonel: Select the correct time zon.
4.6 Video Management
fSystem limer.' Set the correct date and time.
lsync Time]: Tick "Enable" to update the time when connect to the lnternet. The camera offered in the kit has been matched by factory. Power on the lP cameras
[Date Formatl: Select the date format and NVR, the cameras will connect to the NVR automatically.
lLanguagel: Select the language.
4.6.1 Auto Add
4.6.2 Match Code
1. lf you delete the matched camera without intention or try to reset the camera, '1. If you you need to
add a new Wi-Fi camera. Firsfly, take the network
please right-click the mouse button to select',yideo Manage" to enter into the
cable to connect to the NVR'S port or keep the camera and NVR in the
interface of video manage. Cljck "Refresh,' will display the cameras has been same LAN, and then power on the device_Make sure there is still any
added before as shown in the figure below. channel can be added to the camera before adding, and then click
"Refresh" will display the new lP address automatically, as shown
in the figure below

2. Please cltck"Auto Add", and then the Wi-Fi cameras deleted will connect to the
NVR automatically as shown in the figure below.

2. Please click"Match Code" the cameras will connect to the NVR automatically.
Finally, you can pull the network cable out il you has match code successfully.
Step 1: lf you want to change the recording time or recording mode of motion
detection, please click lIime] to set the recording time and click lReset] to
change, as shown in the figure below.

Step 2: Click the left mouse button and drag to set the time frame and the day of
week in the area, as shown in the figure below.
4.7 Video Detection
4.7.1 Time Setup
Right-click the mouse button and select [System setup]-[Record setup], the
default recording lime is 7124, the first line is the time bar shows red, the second
line is the motion bar shows green, and the third is the alarm bar shows yellow, as
shown in the figure below.

Step 3: Click [Copy toJ to select the channels you want to record and click
[Appty]
to save the settings, as shown in the figure below.
4.7.2 Motion Setup
Motion detection is enabled by default, you can go to fsyslern setup]-lohannel 4.7.3 Email Alert Setup
setupl-Nideo detectionl lo enable E-Mail Notice or APP Alarm according to your Right-click the mouse button and select lsyste m setupl-[Network setup]-[E-MAIL]
needs, as shown in the figure below. to setup your email alert, please select SMTP Provider and Encryption Type and
input your SMTP Server, Poft, Sender, Password, Sendee, Subject, Interval, and
click [IestJ to make it work, as shown in the figure below.

lf you want to change motion detection mode, please click fMotiorr] to set the
motion detection and click IResetJ to change. Click the left mouse button and
drag to set the time frame and the day of week in the area as shown in the figure
below. Click lcopy toJ to select the channels you want to detect motion and click
[Apply] 1o save lhe settings, as shown in the figure below.
4. 8 Video Playback
Right-click the m;use button in the Main Menu and select Nicfeo ptaybackl
Choose playback date on the upper right corner and select channel No. Then click
[SearchJ, recording will come out. You can drag the time bar and click [playback]
to start.

1. The date in blue represents there is video record, you can choose to playback.
2. Select and enable the channel to playback.
3. Select the time bar shows red to playback (Red represents regular recording).

4.9 Network Status


Make sure video recorder is connected with network, and lp address is available
before generating lD. Right-click the mouse button andclicklsysternsetupr-
[Network setup]. There is no need to choose DHCp which helps to get iCaddress
automatically if the user is familiar with LAN. lnput lp address and DNS address
manually, video recorder will generate lD by network and appear in the menu. lf the
9loud(P2P) shows "ONLlNE", which means your network status is in,,Healthy
Network", you can watch the video normally on your mobile phone and pC, as shown
in the figure below.

Note.' Playback icff introduction " ll" Ptayback one frame previous, , f,fl " ptayback
oneframe nex, "[" Play, "[["Pause, 'DD"Fastforward aiztime, +times, giimes.

lf the Cloud(P2P) shows"OFFLINE,', which means your network status is abnormal or


in'DNS Request Error". you can click lFast netwotkl to diagnose what's wrong with
the network and solve the problem according to the tips, as shown in the figure
below.
5.1 Access in LAN
Step 1: Right-click the mouse button and click Isystem setupl-[Network setup] to
Eill
check video recorder lP address.
Step 2: Access by computer in the same LAN, input video recorder lP address and
port( If port is 80, no need to input) on lE browser or any other browser. Then it
will access LAN log in web page, input user name and password, click log in.
Step 3: You can get video if you get access successfully.
Tips; Please make sure video recorder and computer in the same network.

EHE
HTE
5.2 Access in WAN
-aE
$,,i{il6..i!i}, r-stli&*&id 'tt Step 1: Right-click the mouse button and clicklsystern sefupr-
I [Network setup] to enable Cloud(P2P)lD.
Step 2: Access by computer in WAN, input wrvw.e-seenef.com on lE browser or any
other browser. Then it will access log in web page, input lD, user name and password,
click"Login".
Note: You can get video if you get access successfully, make sure the upload speed of
NVR and the download speed of computer in each channel above 30kb.

ffi:3:
r;:::=3
l.r{qll 4

{ *.ai:ti&ititea&*.&Kter!*it: :ir,&*fft'1w,,at&wte_,' ,* }
(s.1-2)
5.3 Access in CMS
CMS_client software ,,iE@@ ,,
is in the upplled CD. tt shows tike that
' ll-ltreecloud_s€hrp and open it to login. please click the
" after installation
icon"+"at the upper right corner to add the device, and input your cloud ID,
username, password, note, channel, type to add the device, is shown in the a. Search"lP Pro"in Google Play Store or APP Store, or scan the "Android client
figure below, you will go to the intertaie as shown in the figure below. Iink"or "lOS client link" QR Code on the Setup Wizard
b. Download and lnstall the "lP Pro"APP
c. Open the APP and add the device (as shown in the figure below)
Step 1: Tap"+to add new device
Step 2: Tap to scan the QR code or enter the Device lD interface in setup wizard
step 3: Scan the QR Code in Setup Wizard
Step 4: Live View
A. How to enhance stability of connecting Repeater by Wi-Fi
Repeater is an effective way to solve transmission instability when Wi-Fi camera is far
from the Wi-Fi NVR by connecting the iarther Wi-Fi camera to the nearer one.
'' .t.' Sleps to setup
1. Right-clickthe mouse button to enter[yideo Managel], and then clicktRepeatetl
to enter the setup interface.

le,slel
t&&.s,
G) (2)
@

cMs 8t{ilt6
ffiffi trt&M
&hw M
&#
3. Choose a camera which is near to the NVR(Signal is strong)as a repeater,
then click [+] to choose a camera which is farther from the NVR(Signal is
weak) to connect, then click [Apply]. Click [yes] to save the contiguration.

Note
1. lf there rs a red line betlveen NVR and Camera, which means the signal is too
weak to repeat. You should reduce the distance between NVR and camera, then
4.After configuration, you should wait several minutes for the camera to reconnect
click [RefreshJ.
Then click lRefresh] to get the new repeater status.
2. The intensity signal of the Repeater Camera(nearer one) must be up to 80% lor
:he farther one to connect.

B. Radio antenna extension line


A radio antenna extension line(3 meters long) is used to avoid losing the signal
because o, the obstacle(such as wall) between the NVR and camera. The antenna
extension line should be near to the NVR.

You might also like