Professional Documents
Culture Documents
https://chat.whatsapp.com/I4gbzV5vQ3U9AygWQOlyWm
1
Objective Type Question
Mining Engineering
(Examination for DGMS Mining Mate, Mines Forman, Mining Sirdar, Overman
Second class manager’s Certificate, First class manager’s Certificate, Gas
Testing)
(Coal India Ltd, SAIL, IOCL, ONGC, MOIL, NMDC, GMDC, RSMML, GATE
Exam,PSU,UPSC ,Stae level Exam for Mining Lecturer/ professor and all other
mining related Exams & interview )
1) Sound level of Audio Visual Alarm (AVA) should be at least higher than
theambient noise level.
4) As per Reg.177 of MMR 1961 Every Fence erected on the surface shall once at least
inevery week be
examined by .
2
6) Exhaust / Retarder braking system in a truck;
1. a) Is primarily to protect the service break from excess heat and save wear
1. b) Can stall the engine if the specified engine speed is not maintained
1. d) All above
7) What is the minimum height of Roof in case of flat roof Rest Shelters?
1. e) ‘a’, ‘b’, ‘c’ & ‘d’ are correct f) ‘a’ & ‘b’ are correct
1. g) ‘c’ & ‘d’ are correct h) ‘a’ & ‘d’ are correct
9) No drill shall be used for boring a shot hole unless it allows a clearance of
atleast over the diameter of the cartridge of explosive which it is intended to use.
3
11) What are the “UNSAFE WORKING CONDITIONS” at Mines? Choose from the following.
a) Defective tools or equipment. b) Congestion in the workplace.
c) Narrow roads. d) Improper method of working.
Poorhousekeeping.
e) ) all are correct
f
12) A vehicle transporting EXPLOSIVES shall not be driven at speed
exceeding KMPH.
1. a) 25 b) 20 c) 15 d) 30
13) Voltage shall not exceed Volts for hand held portable apparatus used in
theMines as per CEA Regulations. 2010.
15) Which of the following are the main factors responsible for Blast induced ground
vibrations?
Physio-Mechanical properties of Rock b) Explosive types and their
a)
mass. properties.
c) Irregular shape of free face. d) Ground water table.
e) All above f) ‘a’, ‘b’ & ‘c’ are correct
16) As per 11th National Safety conference the contractor shall not employ or terminatehis
worker without the knowledge of the
4
1. a) Excavators b) Water tankers c) Drilling
equipment d)Dumpers/Tippers
19) First-Aid Room shall have floor space not less than .
20) Notice of accident causing death or serious bodily injury in connection with
miningoperations, in Form IV
hours.
1. a) 24 b) 48 c) 72 d) 12
22) Who will set permanent or temporary speed limits, for any area of the Mine or
anyvehicle or class of vehicle?
23) If any employee contracts a notified occupational disease, the Mine Management
shallsend notice to Regional Inspector in
5
24) To measure the performance of the blast which factor is calculated?
1. a) 60 b) 200 c) 45 d) 500
30) In Opencast Mining, the width which is extracted from the working bench is termed as
6
31) Minimum length of safety fuse at the firing end shall not be less than
32) Who are the persons not holding position of supervision or Management, choose
fromfollowing,
1. a) 1st Apr to 31st Mar b) 1st Jan to 31st Dec c) 1st Jan to 30th Sep d) 1st Oct
to 31st Dec
1. a) Improves mine efficiency, reduces down time and cuts maintenance costs
1. d) All above
7
37) Cracking powder is used in
Mines.
38) Notice of Medical examination under 29D of Mines Rules 1955 shall be given
in
39) Every Women employed in a mine above ground shall be allowed an interval
of not less than hours between the termination of employment on any one day
thecommencement of the next period of employment.
1. a) 11 b) 12 c) 24 d) 16
40) For employees engaged in Driving / HEMM operation jobs, eye refraction test should
beconducted one in Years.
1. a) 2 b) 1 c) 3 d)5
41) The explosives shall be transported to the site of blasting not more
than commencement of charging of the holes.
before the
42) Which of the following are the examples of an inadequately maintained haul road?
1. d) All above
8
43) The energy shall not be transmitted in to a Mine at a voltage exceeding andshall
not be used therein at a voltage exceeding .
44) Pit slope is the angle made by the imaginary line joining the –
1. b) Top most toe of the bench to the bottom most toe of the benc
45) Maximum Exposure Limit of dust prescribed for 8 hrs time weighted average in Mine
workingenvironment.
9
48) A successful accident investigation must answer three questions: What are they?
1. c) Why did they do? 2. Why they couldn’t avoid it 3. What went wrong?
49) Which of the following features should be shown in water danger plan?
1. e) All above
51) If the mine wherein 1600 persons are ordinarily employed, the number of
WorkmenInspector required as per as per Rule 29 Q of Mines Rules 1955.
1. a) 2 b) 3 c) 4 d) 5
53) Pit slope is the angle made by the imaginary line joining the –
10
1. e) Top most crest of the bench to bottom most toe of the
1. f) Top most toe of the bench to the bottom most toe of the benc
54) As per 106 of MMR 1961, No tree, loose stone or debris shall remain within a distance
of ——— from the edge or side of excavation.
1. a) 5 m b) 4m c) 3 m d) 2 m
55) If the percentage of free respirable silica present is 10% in the atmosphere , what is
thepermissible limit of free silica in milligrams per cubic meter of air sampled.
1. a) 1.5 b) 3 c) 10 d) 5
56) As per 173 of MMR 1961, the hydraulic test for the air receiver to be done at a
pressure ofat least —- times the maximum permissible working pressure.
1. Medical certificates should be retained for 5 years from the date of medical
examination
58) The annual returns submitted to the DGMS as per – First Schedule of which form?
11
1. a) Form –I b) Form – II c) Form – III d) Form – IV
61) Miner died due to heart- attack during his duty hours without any injury . which of
thefollowing statements is
12
2. In case of Semi – Mechanised – area of maximum of 4 Mate districts with 2 KM flat
area as radius.
64) The bench height is 6m, depth of the hole is 6.6 m (includes sub grade drilling), spacing
is 4 m, burden is 5 m, the density of the rock is 2, and explosive used is 24kg. Find
thepowder factor.
1. a) 12 b) 10 c) 24 d) 11
65) As per Reg.177 of MMR 1961 Every Fence erected on the surface shall once at least
inevery week be examined by .
66) Which of the following is in the part of ISO (Internal Safety Organisation)
i. Managing Director
ii. Director Technical
iii. Safety officer
iv. None of the above
a) 1 & 2 b) 3 c) 1, 2 &3 d) 4
13
67) Which of the following is true regarding the workers participation in safety
management?
1. b) Committee
1. c) Tripartite committee
68) The number of man days in the year 2014 is 26500, rest days are 54, and non working
daysdue to sick are
46. Find the persons ordinarily employed in the Mine. Consider the yearmeans 365
days.
70) The handling figures of the Mine for the year 2014-15 are as below.
The OB hanlding = 5,00,000 Tonnes , ore production = 2,00,000 Tonnes and densities of OB
and Ore are 2.5 and 3respectively . Find the stripping ratio for the year 2014-15.
2. a) 1: 2.5 b) 2.5 : 1 c) 1: 1 d) 5 : 2
14
71) Which of the following are not the safety features of Belt conveyors?
72) As per DGMS Circular No 36/1972, find the minimum width of the bench with the
followingdata?
The Height of the bench is 7 m , The boom reach of the machine is 6 m , the tipper plying on
the bench , where tipperwidth is 2.5 m and the widest machine Hitachi – Ex800 working on
the bench , where the EX – 800 width is 5.5 m.
7. a) 7.5 m b) 6 m c) 7 m d) 5.5 m
74) If the depth of pit reaches —– meters the scientific study on slope stability will bedone
by scientific agency.
1. a) 60 m b) 75 m c) 50 m d) 100 m
======================================================================
Question Question
Answer Answer
No. No.
1 a 41 a
2 b 42 d
3 d 43 d
15
4 d 44 a
5 b 45 b
6 d 46 e
7 a 47 c
8 e 48 a
9 d 49 e
10 b 50 b
11 f 51 b
12 a 52 d
13 b 53 a
14 d 54 c
15 f 55 a
16 a 56 d
17 d 57 c
18 b 58 c
19 b 59 d
20 a 60 d
21 c 61 c
22 a 62 b
23 d 63 a
24 d 64 b
25 c 65 d
26 c 66 a
27 b 67 d
28 d 68 c
29 b 69 c
30 b 70 c
31 a 71 d
32 f 72 a
33 a 73 a
34 b 74 a
35 c 75 d
36 d
37 a
38 a
39 a
40 b
16
Thanks
17