Professional Documents
Culture Documents
Car 145 Important Questions Dgca PDF
Car 145 Important Questions Dgca PDF
Questions:- d) None
1) Which rule requires approval of 9) The scope of approval is contained in
organisation? (CAR 145)
a) 133A a) Maintenance organisation manual
b) 133B b) Maintenance organisation exposition
c) 133C c) Quality control manual
d) 134B d) None
10) The condition of storage are in
2) CAR-145 rev.1 is harmonised with accordance with the .........................
a) JAR 145 instruction
b) FAR 145 a) Operators
c) CAA 145 b) DGCA ‘s
d) EASA 145 c) Manufacturers
3) CAR 145 is applicable for organisation d) None
maintaining 11) Maintenance man hour plan shows
a) All large aircraft a) Organisation has sufficient staff to
b) Small a/c perform work, plan
c) Commercial a/c b) Prepared by QM
d) Both (a) and (c) c) Approved by maintenance manager
4) Large a/c means d) All of the above
a) MTOM more than 5700kg 12) Minor schedule line maintenance and
b) Multi engine helicopter defect rectification can be carried out by
c) Single engine helicopter a) BAMEL holder of appropriate category
d) Both (a) & (b) b) As in a) have undergone approved type
5) Section............ of EASA regulation the training course
procedure for the regulatory authority has c) As in a) no need of approved course
been covered in d) Only an appropriate AME will carry
a) A, maintenance officer’s handbook out these work
b) B, airworthiness officer’s handbook 13) Whish rule requires licensing of
c) B, Maintenance officer’s handbook personnel
d) A, airworthiness officer’s handbook a) Rule 53
6) Application for approval is given in b) Rule 57
a) CA form 2 c) Rule 62
b) CA form 1 d) Rule 61
c) CA form 3 14) Reference for the component
d) CA form 4 certifying staff is
7) CA form 1 is a) Section 2, L ‘v’
a) Acceptance of post holders b) Section 2, L’x’
b) Approval recommendation form c) Section 2, I’iv’
c) Authorised release certificate d) None
d) None CA form 4 is 15) Repetitive pre flight airworthiness
a) Acceptance of post holders directive can be carried out by
b) Approval recommendation form a) Aircraft commander
c) Authorised release certificate b) Flight engineer
1|Page www.rjworld.com
CAR – 145 IMPORTANT QUESTIONS FOR DGCA PAPER-I
2|Page www.rjworld.com
CAR – 145 IMPORTANT QUESTIONS FOR DGCA PAPER-I
b) 48 hrs b) Owner
c) 72 hrs c) Quality manager
d) 30 days d) DGCA
29) Any occurrence find must be reported 35) Rating A1 is given to
to a) Aeroplanes having weight above 5700
a) DGCA kg
b) State of registry b) Aeroplanes having weight below 5700
c) Organisation responsible for the design kg
d) All of the above c) Multi engine helicopter
30) Certifying staff shall hold a license in d) None
compliance with 36) CA form 6 is for
a) ICAO annex 4 a) Acceptance of post holders
b) ICAO annex 10 b) Approval recommendation form
c) ICAO annex 6 c) Authorised release certificate
d) ICAO annex 1 d) None
31) For staff not qualified according to 37) Maintenance man hour plan should
DGCA licensing requirements shall be reviewed at least every
demonstrate ........... exp. in line a) 3 months
maintenance and ........ in base b) 4 months
maintenance c) 6 months
a) 5yrs, 8yrs d) None
b) 4yrs, 6yrs 38) Significant deviation means
c) 3yrs, 8yrs a) Less than 20% shortfall
d) 2yrs, 5yrs b) More than 20% shortfall
32) Those persons whose authorised task c) Less than 25% shortfall
do not exceed those of CAR sec-2, F part d) More than 25% shortfall
viii, need to demonstrate ............... 39) Human factor training should be
maintenance experience provided to personnel within ............ of
a) 5yrs joining the maintenance organisation
b) 4 yrs a) 3 month
c) 3yrs b) 4 month
d) 2yrs c) 6 month
33) Maintenance that is carried out before d) 1 year
flight to ensure that the a/c is fit for the 40) Temporary staff may need to be
intended flight is called trained on human factor
a) Base maintenance a) 3 month
b) Pre flight inspection b) 4 month
c) Line maintenance c) Need not to be trained subsequent to
d) Both a) and b) his satisfactory knowledge
d) Shortly after joining the organisation
34) For temporary or occasional cases 41) Boroscoping and coin tapping are
who will accept base maintenance task to a) Non destructive inspection
be performed by line maintenance b) Non destructive testing
a) Certifying staff c) Both a) & b)
3|Page www.rjworld.com
CAR – 145 IMPORTANT QUESTIONS FOR DGCA PAPER-I
4|Page www.rjworld.com
CAR – 145 IMPORTANT QUESTIONS FOR DGCA PAPER-I
5|Page www.rjworld.com