Professional Documents
Culture Documents
Electrical Motor Installation Procedure
Electrical Motor Installation Procedure
CONTENTS
1. REFERENCES ....................................................................................................... 1
2. PROCEDURE ........................................................................................................ 1
3. QUALITY CONTROL ............................................................................................ 2
1. REFERENCES
1.1 References
1.1.1 Technical Specification Project Document for Electrical Works:
B-EVE-M-BVT-0068
1.1.2 Manufactures Technical Guides and Manuals
1.1.3 NFPA 70 National Electrical Code
1.1.4 PUIL 2011 Amendments 6,IEC, IEE, International Standard.
2. PROCEDURE
instructions.
2.1.5 Great care shall be exercised to prevent damage to this original finish
2.1.6 Area shall be ready for placement as detail guide from manufacture
manual
2.1.7 All equipment shall be accurately aligned on its foundation and secured in
its place.
2.2.2 Verify that the motor tag are conform with Project Specification, data sheet
equipment system.
2.2.5 Connect cable to terminal motor and check connection bolt tightness as
manufacturer’s recommendation
3. QUALITY CONTROL
3.1 Alignment, level and connection of the equipment are according with Project
Specification.
3.2 Motors in high humidity and defective insulation, space heater is required to be
on.
3.3 Check tag, data sheet equipment are according with Installation approved
drawings.