Professional Documents
Culture Documents
reviewer3@nptel.iitm.ac.in ▼
Unit 3 - Week-I
Course
outline
Assignment 1
The due date for submitting this assignment has passed.
How to access As per our records you have not submitted this Due on 2018-09-12, 23:59 IST.
the portal assignment.
Zero week 1 1)Two metals A and B are immersed in an electrolyte and electrically connected 0 points
with each other as shown in the figure given below. It has been observed that the current
Week-I flows from A to B (as shown in the figure). Which metal will act as an active metal?
Quiz :
Assignment 1
Lecture -1:
Introduction to
corrosion - I
Lecture-2:
Introduction to
corrosion - II
Lecture-3:
Types and
forms of
corrosion
Lecture-4:
Uniform and
Galvanic
corrosion
Lecture-5:
Crevice and
Pitting
corrosion
A
WEEK-1
FEEDBACK B
Funded by
Powered by
Week 7 Oxygen reduction can cause severe corrosion than that by hydrogen reduction
Pitting corrosion can always be easily identified as compared to the uniform
Week-8
corrosion
No, the answer is incorrect.
Score: 0
Accepted Answers:
Oxygen reduction can cause severe corrosion than that by hydrogen reduction
3) Pankaj exposed a piece of brass (70% Cu-30% Zn) to dilute hydrochloric acid. 1 point
After sometimes he observed that the surface of the brass became dull in appearance. In
order to find the reason, he characterized the brass sample with the help of scanning
electron microscope (SEM)/energy dispersive spectroscopy (EDS) techniques. Which of
the following observations are possible in his investigation?
Corrosion of zinc increases due to the presence of FeCl3 in the dilute HCl
solution than that in the absence of FeCl3
The failure of silver bridge was caused by growth of a miniature crack in the
steel eye-bar over the years due to stress corrosion and corrosion fatigue
Parts with smoother surface finish undergo lesser corrosion than those with
rough surfaces
Stainless steel does not suffer with pitting corrosion.
No, the answer is incorrect.
Score: 0
Accepted Answers:
Stainless steel does not suffer with pitting corrosion.
6) Iron was coated with certain metal A. Initially, iron was protected from 1 point
corrosion at room temperature. Therefore, this coated iron was used to make a machine
component which is exposed to a temperature of 800C during its life cycle. After certain
period of installation, it was observed that iron was corroded and coated material was
protected. The possible coating material could be:
Cr
Ni
Zn
Cu
7) Which of the following statements cannot be true in the context of crevice 1 point
corrosion?