You are on page 1of 33

MIMO Mode Control

RA41219EN70GLA0 1
MIMO Mode Control

RA41219EN70GLA0 2
MIMO Mode Control

RA41219EN70GLA0 4
MIMO Mode Control

RA41219EN70GLA0 5
MIMO Mode Control

RA41219EN70GLA0 6
MIMO Mode Control

RA41219EN70GLA0 7
MIMO Mode Control

RA41219EN70GLA0 8
MIMO Mode Control

RA41219EN70GLA0 9
MIMO Mode Control

RA41219EN70GLA0 10
MIMO Mode Control

RA41219EN70GLA0 11
MIMO Mode Control

RA41219EN70GLA0 12
MIMO Mode Control

RA41219EN70GLA0 13
MIMO Mode Control

RA41219EN70GLA0 14
MIMO Mode Control

RA41219EN70GLA0 15
MIMO Mode Control

RA41219EN70GLA0 16
MIMO Mode Control

Transmit Diversity uses two transmit antennas over two symbol periods to transmit
two independent data symbols.
A stream of symbols is transmitted over two antennas. Each symbol is transmitted with
efficiently designed redundancy.
Applicable to control/broadcast channels (PDCCH, PBCH, PHICH, PCFICH), the
synchronization signals (PSS, SSS), and (sometimes) PDSCH
•Not applicable to Reference Symbols

RA41219EN70GLA0 17
MIMO Mode Control

DL adaptive closed loop MIMO (4x2) supports Transmit Diversity for 4 antenna ports in
Transmission Mode 4 (TM4) and in Transmission Mode 2 (TM2).
3GPP has specified open loop Transmit Diversity using one codeword: Precoding Feedback
and Rank Information is not required!
Transmit Diversity using 4 antenna ports is used whenever there is no valid, complete and
consistent Channel State Information available as detected by eNodeB.
During Initialization when RRC setup is performed
No update of valid CSI reports for single layer (RI=1) and dual layer (RI=2)
transmissions since a characteristic update time.
UE does not send valid reports (e.g. Category 1 UEs).
Transmit Diversity for 4 antenna ports is implemented as a combination of SFBC (Space
Frequency Block Coding) with FSTD (Frequency Switched Time Diversity).

RA41219EN70GLA0 18
MIMO Mode Control

RA41219EN70GLA0 19
MIMO Mode Control

RA41219EN70GLA0 20
MIMO Mode Control

RA41219EN70GLA0 21
MIMO Mode Control

RA41219EN70GLA0 22
MIMO Mode Control

RA41219EN70GLA0 23
MIMO Mode Control

RA41219EN70GLA0 24
MIMO Mode Control

RA41219EN70GLA0 25
MIMO Mode Control

RA41219EN70GLA0 26
MIMO Mode Control

RA41219EN70GLA0 27
MIMO Mode Control

RA41219EN70GLA0 28
MIMO Mode Control

CQI Filter:
- For Diversity (Report with Rank = 1) newCQI = WIDEBAND_CQI_Stream1 +
DELTA_CQI*rdMimoOllaUsedXX.
- For Spatial Multiplexing (Report with Rank = 2) newCQI = (WIDEBAND_CQI_Stream1 +
WIDEBAND_CQI_Stream2) / 2 + mimoCqiCompSmDivXX +
DELTA_CQI*rdMimoOllaUsedXX.

During times on inactivity, also the CQI filter shall be slightly modified to provide a slow and
seamless movement towards Diversity Mode independent from mimoXXCqiAvg settings.
For every TTI mimoCQI(t) is decreased by:
mimoCQI(t) = rdMimoCqiAgeing *mimoCQI(t-1)

Averaging:
mimoCQI(t) = (1-mimoXXCqiAvg)*mimoCQI(t-1) + mimoXXCqiAvg*newCQI.

RA41219EN70GLA0 29
MIMO Mode Control

RA41219EN70GLA0 30
MIMO Mode Control

RA41219EN70GLA0 31
MIMO Mode Control

RA41219EN70GLA0 32
MIMO Mode Control

RA41219EN70GLA0 33
MIMO Mode Control

RA41219EN70GLA0 34

You might also like