Professional Documents
Culture Documents
net/publication/287207744
CITATIONS READS
0 1,543
4 authors, including:
Some of the authors of this publication are also working on these related projects:
cuttings transport in horizontal and highly deviated wellbores drilled with coiled tubing View project
THE STUDY OF SCALE FORMATION IN OIL RESERVOIR DURING WATER INJECTION AT HIGH-BARIUM AND HIGH-SALINITY FORMATION WATER View project
All content following this page was uploaded by Amer Badr Binmerdhah on 23 February 2017.
Figure 1: Ideal radial flow model for edge-water drive system [2]
1
Prediction of Water Influx Effect on Oil Production………………. Amer Badr BinMerdhah et al
Description of Biyad oil reservoir: from the reservoir to the surface. The produced
Block 10, operated by TOTAL E&P Yemen, water has been returned to the formation to offset
produces an average of 28,000 STB/day mainly the reservoir pressure decline. The Biyad
from its two fields, Kharir and Atuf [10]. On the formation and production data used in this study
Atuf field, the main reservoir is located in the are given in Table 1.
Biyad sandstone formation. The objective of this paper is to investigate the
Biyad oil reservoir contains fourteen wells, water influx into a sandstone Biyad reservoir by
twelve of them are producing oil and two wells using MBE and Van Everdingen and Hurst
are using for water injection as shown in Figure unsteady state model and comparing between
3. The reservoir mechanism is edge water drive, their results. This work was also intended to
but after a period of production electric predict the reservoir future performance for the
submersible pumps (ESP) is used to lift the oil next two years.
Prediction of Water Influx Effect on Oil Production………………. Amer Badr BinMerdhah et al
Formation Data
Initial reservoir pressure, psia 1623
Bubble point pressure, psia 40
Water saturation 70 %
Formation porosity 19 %
Formation permeability, md 832
Formation temperature, ºF 181
Salinity, ppm 335000
Water viscosity, cp 0.43
Radius of reservoir, ft. 15000
Production Data
Or (1)
(2)
(3)
(4)
(5)
(6)
(7)
Water formation volume factor, water and formation compressibilities can be calculated by using the
following equations [1]:
(8)
(9)
(10)
(11)
(12)
Prediction of Water Influx Effect on Oil Production………………. Amer Badr BinMerdhah et al
(13)
(14)
(15)
(16)
(17)
(18)
(19)
When a new field is discovered, one of the first a. All the calculated points of F/(Eo+Ef,w) lie on
tasks of the reservoir engineer is to determine if a horizontal straight line (see Line A in
the reservoir can be classified as a volumetric Figure 4). Line A in the plot implies that the
reservoir can be classified as a volumetric
for each pressure and time observation is plotted reservoir.
versus cumulative production Np or time, as b. If the calculated points of F/(Eo+Ef,w) rise, as
shown in Figure 4. Dake (1978 and 1994) [6,7] illustrated by the curves B and C, this
suggested that such plot can assume two various indicates that the reservoir has been
shapes, which are: energized by water influx.
Van Everdingen and Hurst unsteady state also expressed as a function of the dimensionless
model: time tD and dimensionless radius rD, so they
Van Everdingen and Hurst expressed their made the solution to the diffusivity equation
mathematical relationship for calculating the generalized and applicable to any aquifer where
water influx in a form of a dimensionless the flow of water into the reservoir is essentially
parameter that is called dimensionless water radial as shown in Figure 5.
influx WeD. The dimensionless water influx is
Hadhramout University Journal of Natural & Applied Sciences, Volume 12, Issue 1, June 2015
W eD
1 0.616599 t D 0.0413008t D
(28)
4.29881 2.02566 t D
c. For tD > 200 W eD (29)
ln t D
Prediction of Water Influx Effect on Oil Production………………. Amer Badr BinMerdhah et al
Water influx calculations for given data: and Hurst unsteady Equation (25). Their
a. From Figure 7, the Original oil in place (N) = results are shown in Figure 8. As may be seen
247,098,662.6 STB and the water influx in Figure 8, the points almost make straight
constant (B) = 68.068 bbl/psi. line, so the water influx results from each
b. The water influx is calculated using material method (MBE and Unsteadystate Model)
balance Equation (6) and Van Everdingen agree very well.
Prediction of Water Influx Effect on Oil Production………………. Amer Badr BinMerdhah et al
(30)
Prediction of Water Influx Effect on Oil Production………………. Amer Badr BinMerdhah et al
Prediction of oil and water produced and Moreover, the reservoir pressure falls slowly and
water injected as function of pressure: continuously with water injected because of that
As shown in Figures 10 and 11, the reservoir injected water offset the reservoir pressure
pressure declines rapidly and continuously with decline as shown in Figure 12.
increasing amount of produced oil and water. From Figures 10-12, oil and water produced and
This is due to the fact that the water encroached water injected were predicted by the following
and injected into the reservoir is not sufficient to equations and their results are given in Table 2:
replace the produced oil and water.
(31)
(32)
(33)
Prediction of Water Influx Effect on Oil Production………………. Amer Badr BinMerdhah et al
Prediction of Water Influx Effect on Oil Production………………. Amer Badr BinMerdhah et al
التنبؤ بتأثري تدفق املياه على إنتاج النفط يف مكمن بياض النفطي
الملخص
المكامن النفطية غالباً ما تحاط من الجوانب أو األسفل بمجمعات مائية التي بدورها تدعم ضغط المكمن من خالل تدفق المياه .وردا على
انخفاض الضغط في المكمن النفطي ,المياه الجوفية تتفاعل مع تعويض ,أو تأخير انخفاض ضغط المكمن من خالل توفير مصدر تدفق
المياه .وقد اهتم الباحث بتحديد تدفق المياه إلى مكمن بياض النفطي باستخدام معادلة توازن المادة و نموذج فان إفردنجن وهيرست
والمقارنة بين نتائجمها .و كما هدفت الدراسة إلى التنبؤ بأدائية المكمن المستقبلية لسنتين قادمة .وأكدت النتائج أن المكمن يحتوي على
الدفع المائي لدفع النفط باتجاه البئر وأن كمية النفط الموجودة في حقل بياض تقدر 742مليون برميل .و أيضا تم التنبؤ بتدفق المياه إلى
المكمن النفطي لسنتين قادمة بطريقة معادلة موازنة المادة و نموذج فان إفردنجن وهي رست وكانت النتائج في اتفاق جيد مع متوسط الخطأ
المطلق يساوي %.5...1
كلمات مفتاحيه :إنتاج النفط ,تدفق المياه ,مكمن بياض النفطي ,معادلة توازن المادة ,نموذج فان إفردنجن وهيرست.