Professional Documents
Culture Documents
RR220D4AR2
RR220D4AD2
2
Note: Due to continual modification of our products, your refrigerator may be slightly different
from this instruction Manual, but its functions and usage methods remain the same.
Control panel
Starting up and temperature regulation Important! Normally, we advise you select a
Insert the plug of the connection lead into setting of 2, 3 or 4; if you want the
the plug socket with a protective grounding temperature higher or lower, please turn the
contact. When the refrigerator compartment knob to a warmer or colder setting
door is opened, the internal lighting is accordingly. When you turn the knob to a
switched on. colder setting, this can lead to the more
The temperature selector knob is located on energy efficiency. Otherwise, it would result
the back side of the refrigerator the consumption of energy.
compartment. Important! High ambient temperatures (e.g.
Setting “off” means no cooling on hot summer days) and a cold setting
Turn the temperature control to “off” position (position 6 to 7) may cause the compressor
stops the cooling cycle,but does not shut off to run continuously or even non-stop!
the power of the refrigerator. Reason: When the ambient temperature is
Setting “1” means high, the compressor must run continuously
Highest temperature, warmest setting. to maintain the low temperature in the
Setting “7” (end-stop) means appliance.
Lowest temperature, coldest setting. Warning!
Don’t try to repair the appliance
and change the LED light
yourself.
If the LED light can’t work, please contact
your specialist dealer or your local
Customer Service Center to change it.
9
100mm
100mm 100mm
664mm
Before using the appliance for the first
978mm
time, wash the interior and all internal
accessories with lukewarm water and 140°
meutral soap in order to remove the
typical smell of a brand new product, then 75mm 100mm
980mm
dry thoroughly.
Installation Positioning
Warning! Before installing, read the Appliances must not be exposed to rain.
instruction carefully for your safety Sufficient air must be allowed to circulate
and the correct operation of appliance. in the low rear section of the appliance, as
Position the appliance away from sources poor air circulation can affect performance.
of heat such as stoves, radiators, direct Built-in appliances should be positioned
sunlight, etc. away from heat sources such as heaters
Maximum performance and safety are and direct sunlight.
guaranteed by maintaining the correct
Installing the rubber supporting
indoor temperature for the class of unit
concerned, as specified on the rating plate. screw provided in a plastic bag with your
This appliance performs well from N to ST. appliance, you can install these
The appliance may not work properly if it is accessories according to the following
left for a longer period at a temperature procedure.
above or below the indicated range. Note:
There is no need to install these
accessories under normal usage.
Only under the extreme circumstances,
cabinet empty while load on door with total
mass of 15 kg and opening the door about
90 degree ,this refrigerator may take risk
of tipping. Then rubber supporting pad
should be fastened to the lower base
Important! It is necessary to have good
cover to steady this appliance.
ventilation around the fridge to allow for the
dissipation of heat, high efficiency an low 1.Tilt appliance to find screw hole on the
sufficiently cleared space should be left of lower base cover.
available around the fridge. It is advisable for
there to be 75mm separating the back of the
fridge to the wall at least 100mm of space on
its two sides, a height of over 100mm from
its top and a clear space in front to allow the
doors to open 160°.
Daily use
Accessories 1)
Movable shelves/trays
Various glass, plastic storage shelves or
wine rack are included with your appliance
different models have different
combinations and different models have
different features.
Crisper
For storing fruit and vegetables.
Ice tray
It is used for making ice. Refrigerator compartment 2)
There are some notes during the ice
For storing the food that does not need to
making:
1. If the ice tray is used for the first time be frozen and different sections suitable
or has not been used for a long time, for different kinds of food.
please clean it before using.
2. When you pour water into the ice
Freezer food compartment 2)
tray, the water level shall not exceed For freezing fresh food and storing frozen
the top line. and deep-frozen food for a long time.
Thawing food 2)
Cooked foods, cold dishes, etc...: these Note: If the appliance contains related
should be covered and may be placed on accessories and functions.
any shelf.
13
What to do if...
Warning! Before troubleshooting, performed by competent service engineers.
disconnect the power supply. Only a Improper repairs can give rise to significant
qualified electrician or other hazards for the user. If your appliance
personnel must carry out the needs repairing, please contact your
troubleshooting that is not in the manual. specialist dealer or your local Customer
Service Center.
Important!
Repairs to the appliance may only be
Problem Possible cause Solution
Appliance is not switched on. Switch on the appliance.
Main plug is not plugged in or is Plug the appliance into the
Appliance dose not
loose. electrical socket.
work.
Fuse has blown or is defective. Check fuse, replace if necessary.
Outlet is defective. Defective parts need to be
repaired by an electrician.
Appliance cools too Turn the temperature regulator to
Temperature is set too cold.
much. a warmer setting temporarily.
Temperature is not properly Please refer to the “Initial Start
adjusted. Up” section.
Door was open for an extented Open the door only as long as
period. necessary.
The food is too warm.
A large quantity of warm food Turn the temperature regulator to
was placed in the appliance a warmer setting temporarily.
within the last 24 hours.
The appliance is near a heat Please refer to the “Installation
source. Location” section.
Interior lighting dose Please look in the “Control panel”
LED light is defective.
not work. section.
Carefully warm the leaking
Heavy build-up of Door seal is not air-tight sections of the door seal with a
frost, possibly also on (possibly after reversing the hair dryer (on a cool setting). At
the door seal. door) . the same time, shape the
warmed door seal by hand so
that it sits correctly.
Appliance is not level. Readjust the feet.
The appliance is touching the
Move the appliance slightly.
Unusual noises. wall or other objects.
A component, e.g. a pipe, on
the rear of the appliance is If necessary, carefully bend the
touching another part of the component out of the way.
appliance or the wall.
The compressor dose
not start immediately This is normal, no error has The compressor starts after a
after changing the occurred. period of time.
temperature setting.
Water on the floor or Refer the “Cleaning and Care”
Water drain hole is blocked.
storage shelves. section.
15