Professional Documents
Culture Documents
Hard Drive Repair1
Hard Drive Repair1
successfully. Watch Out! Both devices are plastic and one in the next step
121
both are very fragile and can be easily broken if pushed too hard!
13) Gently slide the head from the disk. DO NOT touch the head with a finger
14) Now, hold the head that does not move by holding your finger on
bearing top.
15) While doing this, turn the drive slowly. You will see a Torx
under the screw head (under the controller that you loose earlier). Release
screw carefully.
16) Lift head straight out of the chassis. When finished, gently pull on the block connection
www.agussale.com
Qbonk Media Group - Ebook sales consultation center and Engineers PC, Laptop Technician, Network Technician www.dpcworld.com
www.revolusibisnisonline.com
PC, Online Business
www.qbonk.com
Qbonk Media Group Jln Gassing Dg
Tiro - Gowa (Sulawesi)
E-mail: iteknisi@gmail.com , agussale@gmail.com
Mobile: +6282190987762
122
replace head stack from a backup to a hard drive that will be fixed !!!
2) I have also included a very simple quick sketch of of the topic that we
talking on
www.agussale.com
Qbonk Media Group - Ebook sales consultation center and Engineers PC, Laptop Technician, Network Technician www.dpcworld.com
www.revolusibisnisonline.com
PC, Online Business
www.qbonk.com
Qbonk Media Group Jln Gassing Dg
Tiro - Gowa (Sulawesi)
E-mail: iteknisi@gmail.com , agussale@gmail.com
Mobile: +6282190987762
123
Last note:
www.agussale.com
Qbonk Media Group - Ebook sales consultation center and Engineers PC, Laptop Technician, Network Technician www.dpcworld.com
www.revolusibisnisonline.com
PC, Online Business
www.qbonk.com
Qbonk Media Group Jln Gassing Dg
Tiro - Gowa (Sulawesi)
E-mail: iteknisi@gmail.com , agussale@gmail.com
Mobile: +6282190987762
For several reasons that may not be realized, maybe your hard drive connector
broken. Due to unintentional bias, the bias is also due to carelessness. It is clear that this
not easy but it can be done. First, prepare Bonder Loctite Plastix. This fluid bias
1. Make sure the hard disk is damaged already ready to be done, and make sure the location
2. The first step is to remove the solder pieces are broken and
unplugging.
3. The scenario is that we would melt the plastic with Bonder Plastix
4. Take sediki plastic, clear plastic try and mix with Bonder
This plastic with any arbitrary plate. Please think about how.
not broken
www.agussale.com
Qbonk Media Group - Ebook sales consultation center and Engineers PC, Laptop Technician, Network Technician www.dpcworld.com
www.revolusibisnisonline.com
PC, Online Business
www.qbonk.com