Professional Documents
Culture Documents
Multimeter 560CVD03
Data sheet
Dis-
Type
Versions play LO HI 1A 5A
Characteristics
The Multimeter is a microprocessor-based Intelligent Electron-
ic Device (IED) intended for current, voltage, power and energy
Figure 1: 560CVD03 without LCD Display
measurement.
Application The display is available for the versions R003x and R005x. It
switches automatically the displayed measurement page screen.
The Multimeter 560CVD03 is used for measuring analog AC in-
put signals from three independent phases. For each phase volt- The scroll mode can configured with RTUtil500:
age and current are measured directly and a number of calcu- – Manual mode: Each screen will be displayed for 4 minutes.
lated values are generated by the module. The module supports The push button can be used for switching the pages man-
configurations with 2 or 3 voltage transformers. ual.
– Scanning mode: Each screen will be displayed for 6 sec-
There are several versions available: onds.
Dis-
Type
Versions play LO HI 1A 5A
3 Phase 4 Wire
Source Load
RS-232
Figure 4: Power measurement convention
Energy values
Power RS-485 Integrated total (intermediate and end of period readings) are
calculated for:
Figure 3: 3 phase, 4 wire connection (3P4W) – active energy negative
– active energy positive
– reactive energy capacitive
Meter Operation – reactive energy inductive
The following measured or calculated values are available from Voltage / Current Distortion (THD)
the module.
The 560CVD03 provides a measure of the total harmonic distor-
Instantaneous Meter Values tion (THD), in each phase voltage and current waveform, as a
percentage deviation from pure 50Hz or 60Hz sine waves.
Following values are measured by true RMS conversion
THD is calculated by Fast Fourier Transform algorithm (FFT) for:
Measurement Measuring Path – U1, U2, U3
– I1, I2, I3
Neutral voltage Phase 1-N, 2-N, 3-N
Current Phase 1, 2, 3
Frequency System
Load : < 0.3 VA per phase Mounting DIN rail mounting EN 50022 TS35: 35
Input impedance: 1 MΩ mm x 15 mm or 35 mm x 7.5 mm
Harmonics Up to 15th harmonic for 50/60 Hz Dielectric Strength IEC 60255-5 2 kV AC rms, 1 minute
68128 Mannheim, Germany poses and shall in no respect be binding. The Brochure does not claim to be ex-
haustive. Technical data in the Information are only approximate figures. We re-
www.abb.com/substationautomation serve the right at any time to make technical changes or modify the contents of
this document without prior notice. The user shall be solely responsible for the
use of any application example or information described within this document.
The described examples and solutions are examples only and do not represent
any comprehensive or complete solution. The user shall determine at its sole
discretion, or as the case may be, customize, program or add value to the ABB
products including software by creating solutions for the end customer and to
assess whether and to what extent the products are suitable and need to be ad-
justed or customized.
ABB AG reserves all rights in particular copyrights and other intellectual property
rights. Any reproduction, disclosure to third parties or utilization of its contents -
in whole or in part - is not permitted without the prior written consent of ABB AG.