Professional Documents
Culture Documents
Objective:
Chemicals:
Procedure:
1. The round bottom flask was filled with 25ml of 30% ethanol. Few boiling chips was
added.
2. A simple distillation apparatus was set up as shown in diagram. The thermometer
was put into the the thermometer pocket.
3. The liquid was heated at constant rate during the boiling, which was until the
distillation rate was about 2-3 drops per second.
4. A stable temperature was recorded as the boiling point of the liquid to be distilled.
5. The ethanol collected was measured after distillation.
6. The percentage yield of recovery was calculated.
A.
Start 78
End 84
Volume (ml)
30
Initial volume of ethanol in 25ml ×100 %=7.5
100
6.9
Calculation of ethanol after distillation ×100 %=92%
7.5
Questions/Discussions:
3. Ethanol have higher boiling point than propane. Draw the structure of ethanol
and propane ann explain why.
Ethanol Propane
Ethanol forms bonds between oxygen and hydrogen molecule whereas propane form
only hydrogen bonds. Hydrogen bonds are weaker than hydro-oxi bonds thus it takes
more heat to break O-H bond than H-H bonds.
4. What is the thereotical value of ethanol’s boiling points? Compare the value
with your experimental value of boiling point. Explain why it is differ.
The thereotical value is 78˚C while experimental value is 79˚C. During the distillation,
at 92% ethanol-water mixture forms azeotrope which hampers further distillation. So
ethanol can be made 100% pure.
Conclusion:
As a conclusion, the techniques of distillation was learned and the boiling point of
ethanol was determined. Only 92% of ethanol was recovered from the distillation
process. This may be due to the ethanol vapour is still trap in the apparatus during
the boiling process.