Professional Documents
Culture Documents
1 WCDMA Access Counters and KPIs Introduction PDF
1 WCDMA Access Counters and KPIs Introduction PDF
1
In WCDMA signaling procedure, a complete
access process contains following steps:
RRC establishment
Initial DT
Authentication
Security mode
RAB assignment
2
Upon completion of this course, you will be able to:
3
Chapter 1 RRC Establishment Counter and KPI
Node B Serving
UE
Serving RNS RNC
Allocate RNTI
Select L1 and L2
parameters
2. Radio Link Setup Request
NBAP NBAP
Start RX
description
3. Radio Link Setup Response
NBAP NBAP
5. Downlink Synchronisation
DCH - FP DCH - FP
6. Uplink Synchronisation
DCH - FP DCH - FP
Start TX
description
7. CCCH : RRC Connection Set up
RRC RRC
8. Radio Link Restore Indication
NBAP NBAP
4
RRC Establishment Counter and KPI
Originating Subscribed Traffic Call: Any other service not defined in the
4 QoSs.
Originating High Priority Signaling: e.g. Supplementary Services,
Location services, Modify PDP Context, Deactivate PDP Context, etc.
Originating Low Priority Signaling: e.g. SMS
Cause Unknown: UE cannot map the NAS reason to AS reason that is
defined in the protocol
5
RRC Establishment Counter and KPI
6
RRC Establishment Counters and KPI
RRC Establishment Counters
− Iub failure
7
RRC Establishment Counters
8
RRC Establishment Counters
9
RRC Establishment Counters
RRC.AttConnEstab.OrgStrCall RRC.AttConnEstab.IRATCCO
RRC.AttConnEstab.OrgInterCall RRC.AttConnEstab.Reg
RRC.AttConnEstab.OrgBkgCall RRC.AttConnEstab.Detach
RRC.AttConnEstab.OgSubCall RRC.AttConnEstab.OgHhPrSig
RRC.AttConnEstab.TmConvCall RRC.AttConnEstab.OgLwPrSig
RRC.AttConnEstab.TmStrCall RRC.AttConnEstab.CallReEst
RRC.AttConnEstab.TmInterCall RRC.AttConnEstab.TmHhPrSig
RRC.AttConnEstab.TmBkgCall RRC.AttConnEstab.TmLwPrSig
RRC.AttConnEstab.EmgCall RRC.AttConnEstab.Unknown
10
RRC Establishment Counters
11
RRC Establishment Counters
12
RRC Establishment Counters
13
RRC Establishment Counters
14
RRC Establishment Counters
VS.RRC.FailConEst.RNC :
− When the RNC receives an RRC CONNECTION REQUEST message from the UEs
and if the RRC connection setup fails, the measurement of this item is triggered
VS.RRC.FailConEst.Cng.RNC :
15
RRC Establishment Counters
− The measurement is triggered when the RNC does not receive the RRC CONNECT
SETUP COMPLETE messages upon sending of RRC CONNECT SETUP
messages
− The RNC measures the item in the cell that the UE camps on
16
RRC Establishment Counters
VS.RRC.Rej.RL.Fail
− Radio link setup failure
VS.RRC.Rej.AAL2.Fail
− AAL2 setup failure
17
RRC Establishment Counters
RRC.FailConnEstab.Cong [CELL]
− This measurement item provides, upon the receipt of RRC CONNECTION REQUEST messages, the
number of RRC CONNECTION REJECT messages from the RNC to UEs in a cell due to network
congestion
18
RRC Establishment Counters
19
RRC Establishment KPI
Formula
RRCConnectionSuccess
RRCS _ SR = *100%
RRCConnectionAttempt
Measurement scope:
− RNC & Cell
Description
− This KPI can be used to evaluate RRC setup success ratio about
CS service, PS service and other reasons
20
RRC Establishment KPI
Counters (Cell)
21
RRC Establishment KPI
Counters (Cell)
22
RRC Establishment KPI
Counters (RNC)
Counters (Cell)
23
RRC Establishment KPI
Counters (Cell)
24
RRC Establishment KPI
Counters (RNC)
Counters (Cell)
25
Chapter 1 RRC Establishment Counter and KPI
UE RNC CN
Common ID
DL DT (Authentication
DL DT (Authentication Request)
Request)
DL DT (Authentication
Request) DL DT (Authentication
Request)
Security Mode Command
Security Mode Command
RAB Assignment
26
Security Mode Counter and KPI
Formula
SMCSuccess
SMC _ SR = *100%
SMCAttempt
Measurement scope:
− RNC
Description
27
Security Mode Counter and KPI
Counters
− SMCAttempt
▪ VS.IU.Att.SecMode
− SMCSuccess
▪ VS.IU.Succ.SecMode
▪ The measurement is triggered at point B as shown in the figure, that is, when
RNC sends Security Mode Complete to CN
28
Chapter 1 RRC Establishment Counter and KPI
UE NodeB RNC CN
RAB Asg Req
RANAP RANAP
Q.AAL2
AAL2 Setup Req Q.AAL2
NBAP
RL Recfg Prepare NBAP
Q.AAL2
AAL2 Setup Resp Q.AAL2
FP
DL Sync FP
UL Sync
FP FP
RRC
RB Setup RRC
RRC
RB Setup Complete RRC
29
RAB Establishment Counter and KPI
CS RAB counter system in RNC
CS RAB establishment Attempt:
▪ CS Conversational; CS Streaming
▪ Conv0.32; Conv32.64
▪ Str0.32; Str32.64
▪ Conv0.32; Conv32.64
▪ Str0.32; Str32.64
30
RAB Establishment Counter and KPI
CS RAB counter system in Cell
CS RAB establishment Attempt
− Based on Qos (P34)
▪ CS Conversational; CS Streaming
− Based on typical services (P35)
▪ AMR; CS64
− Based on AMR service rates (P35)
▪ AMR 12.2, 7.95, 5.90, 4.75
CS RAB establishment Success
− Based on Qos (P36)
▪ CS Conversational; CS Streaming
− Based on typical services (P37)
▪ AMR; CS64
− Based on AMR service rates (P37)
▪ AMR 12.2, 7.95, 5.90, 4.75
31
RAB Establishment Counter and KPI
PS RAB counter system in RNC
PS RAB establishment Attempts:
− Based on QoS (P38)
▪ Conversational, Streaming, Interactive, Background
− Based on different service rate (ranges) and QoS (P39)
▪ Conversational 0.32.+
▪ Streaming 0.32.64.144.384.+
▪ Interactive 0.32.64.144.384.+
▪ Background 0.32.64.144.384.+
− Based on typical PS service rates (P39)
▪ PS64, PS128, PS384
32
RAB Establishment Counter and KPI
PS RAB counter system in Cell
PS RAB establishment Attempts:
− Based on QoS (P38)
▪ Conversational; Streaming; Interactive; Background
− Based on different service rate (ranges) and QoS (P39)
▪ Streaming 0.32.64.144.384.+
▪ Interactive 0.32.64.144.384.+
▪ Background 0.32.64.144.384.+
PS RAB establishment Successes:
− Based on QoS (P40)
▪ Conversational; Streaming; Interactive; Background
− Based on different service rate (ranges) and QoS (P41)
▪ Streaming 0.32.64.144.384.+
▪ Interactive 0.32.64.144.384.+
▪ Background 0.32.64.144.384.+
33
RAB Assignment Counter
− RAB.AttEstabCS.Strm
34
RAB Assignment Counter
35
RAB Assignment Counter
36
RAB Assignment Counter
37
RAB Assignment Counter
38
RAB Assignment Counter
39
RAB Assignment Counter
40
RAB Assignment Counter
41
RAB Assignment KPI
Formula
RABSetupSu ccess
RABS _ SR = × 100%
RABSetupAt tempt
Measurement scope:
− RNC & Cell
Description
− This KPI can be used to evaluate the RAB setup success ratio for
different service in RNC or cell.
This KPI can not be used to evaluate the call setup success ratio, unless
the related RRC procedure of the call is successful.
42
RAB Assignment KPI
Counters (RNC)
Counters (Cell)
43
RAB Assignment KPI
Counters (RNC)
Counters (Cell)
44
RAB Assignment KPI
Counters (RNC)
45
RAB Assignment KPI
Counters (RNC)
46
RAB Assignment KPI
Counters (RNC)
47
RAB Assignment KPI
Counters (Cell)
− HSDPARABSetupAttempt : VS.HSDPA.RAB.AttEstab
− HSDPARABSetupSuccess : VS.HSDPA.RAB.SuccEstab
Counters (Cell)
− HSUPARABSetupAttempt: VS.HSUPA.RAB.AttEstab
− HSUPARABSetupSuccess: VS.HSUPA.RAB.SuccEstab
48
RAB Failure Counters
− VS.RAB.FailEstabCS.RNL
▪ VS.RAB.FailEstCS.Relo
▪ VS.RAB.FailEstCS.RIPFail
− VS.RAB.FailEstCS.Unsp
VS.RAB.FailEstCS.Unsp: i.e.: The requested RAB is not supported. Possible reasons for
this include:
49
RAB Failure Counters
▪ VS.RAB.FailEstCs.Power.Cong
▪ VS.RAB.FailEstCs.ULCE.Cong
▪ VS.RAB.FailEstCs.DLCE.Cong
▪ VS.RAB.FailEstCs.Code.Cong
− VS.RAB.FailEstab.CS.DLIUBBand.Cong
− VS.RAB.FailEstab.CS.ULIUBBand.Cong
50
RAB Failure Counters
− VS.RAB.FailEstPS.RNL
▪ VS.RAB.FailEstPS.Par
▪ VS.RAB.FailEstPS.Relo
▪ VS.RAB.FailEstPS.RIPFail
▪ VS.RAB.FailEstPS.Unsp
− VS.RAB.FailEstPS.NResAvail
VS.RAB.FailEstPS.Unsp: i.e.: The requested RAB is not supported. Possible reasons for
this include:
of memory, etc.
51
RAB Failure Counters
▪ VS.RAB.FailEstPs.ULCE.Cong
▪ VS.RAB.FailEstPs.DLCE.Cong
▪ VS.RAB.FailEstPs.Code.Cong
▪ VS.RAB.FailEstab.PS.ULIUBBand.Cong
▪ VS.RAB.FailEstab.PS.DLIUBBand.Cong
52
Chapter 1 RRC Establishment Counter and KPI
53
RB Counter System
54
RB Counter System
55
RB Counter System
− VS.AttRBRecfg
Radio Bearer reconfiguration may happen, e.g. due to DCCC rate upsize or downsize or
UE state transition.
56
RB Counter System
− No reply: VS.FailRBRecfg.NoReply
57
Summary
58
Thank you
www.huawei.com
59