Professional Documents
Culture Documents
Ads by Google ► Power AC DC ► TV Repair ► Power Fuse ► Power LED
Cause:
All these symptom are causing by the PFC voltage output
drop below 370V, typically when occur the above
symptoms their PFC output voltage is about 340V~ 360V or
below 370V. What will cause the PFC output voltage drop?
Actually they are many reasons, but in this case, it is
because of their PFC IC pin-1 VFB (Voltage Feedback)
sampling circuit line corresponding component/s leakage.
Especially their voltage divider resistors are a common
fault of this strange problem in TV power supply (PSU). It is
because of these divider resistors leakages and it is causing
because of these divider resistors leakages and it is causing
by the red glue (Seal Glo) under these SMD resistor. For
example the RSAG.7.820.1673 PSU board (normally call it as
1673 board), their divider resistors R823, R824 & R825 are
inside the PFC section as photos below:
Repair/Solution:
Removed these divider resistors, cleaning their PCB board
red glue and also the red glue attached on the bottom of
SMD resistor. After clean all these red glue from the above
divider resistors (R823, R824 & R825) and solder it back to
their appropriate location. Finally this type of strange
problems in LED TV was solved. Remember, not all the
above PSU board their divider resistor is same these
R823~R825, may be different part number of PSU board
will vary. But their reason is same, is because of the PFC IC
pin Voltage Feedback sampling circuit line component/s
was leakage and caused these strange problem occur.