Professional Documents
Culture Documents
FTKQ Series
What is Inverter
An Inverter is energy saving technologythat eliminates wasted operation in air conditioners by efficently contolling motor speed.
Comfort
Daikin Swing Compressor
Needs Proposals
Normal operation
Handles from
150 V to 440 V Max.
Power consumption
440 V
150 V
Econo Mode
When the voltage is higher or lower than the operable range, the air conditioning Time
system switches itself off. When the voltage is adjusted back to its original value, the
system automatically starts operating again. Maximum capacity decreases during Econo Mode, requiring more time
to reach the set temperature.
• Outdoor come with anti-corrosion heat exchanger fin. • R32 does not deplete the ozone layer unlike R22.
• Surface coated with a thin acrylic resin layer to provide enhanced • R32 is 1/3 lower in gobal warming potential comparing with
resistance to acid rain and salt corrosion. R410A.
• R32 has 9 % lower liquid density compared to R410A. In a same
system, R32 charge is lesser than R410A.
• R32 is single component refrigerant which makes it easy to repair
Cross section of anti-corrosion treated fin
and top up.
Hydrophilic film
Aluminium • R32 has the same pressure as R410A enable the installer to reuse
Corrosion-resistant the same copper pipe.
acrylic resin
in GWP R32
(HFC)
1,810
675
CO2
1
Specifications FTKQ Series Cooling Only
Measurement conditions
1. Cooling capacity is based on: indoor temp. 27°CDB, 19°CWB; outdoor temp. 35°CDB; piping length 7.5 m.
2. Sound pressure levels are measured in an anechoic chamber based on the temperature conditions in 1 above. These are anechoic conversion values. These values are normally somewhat higher during
actual operation as a result of ambient conditions.
Specifications, designs and other content appearing in this brochure are current as of September 2019 but subject to change without prior notice. © All rights reserved.