Professional Documents
Culture Documents
:Steps
In the command bar we write point ●
Then we write the coordinate of the first point 100,100 then press enter ●
Then we repeat the same thing on the rest of the points by writing point and then the ●
coordinate of the next point 105,100
After completing the marking of all the coordinates, we make sure to activate the 3D ●
Object snap command and make sure of the vertex marking
We write the line command and then select between points with line with the help of ●
snap on vertex
.…Then we named the points A,B,C,D ●
Figure 2
: Steps
Then we make a line from the center of the small circle towards Y with a length ●
of 25
Then from the end of the line head we make the second circle with a diameter ●
of 5
Then we select the line command and by pressing right click and shift we select ●
the snap tangent and then we click on the first circle,then repeat the process by
selecting the tangent and then the second circle
When completing the tangent to the circle, we work for the inner lines ●
We create a line from the center of one of the two circles to the middle of the ●
circle with a diameter of 20
We make two copies of the shape after making a block for it ●
We rotate it at an angle of 120 ●
We also perform the same steps for the second shape, after transferring the ●
first coordinate, and rotate it to 240 degrees
.We return the third copy of the shape to the original coordinate ●
Then we select the line and by pressing right click of the mouse, we select the ●
tangent to the circle and we make a line that touches the circle from the
outside on the circumference of the shape
.Next we select FILLET at 30 for intersections ●