Professional Documents
Culture Documents
Lab 01
Lab 01
Lab Report 01
Submitted to:
Engr. Muhammad Basit Shafiq
Submitted by:
Muhammad Arslan
Reg. #:
ME171054
Semester:
6th
Experiment 01
Objective
Page 2 of 4
Determination of thermal conductivity of different metal samples
Apparatus
The apparatus shown in Fig. 1, consists on an input heat section, several central sections of
metallic material with different thermal conductivities and a refrigeration section. The input heat
section is provided of a cylindrical metal bar for the realization of a series of experiments of heat
transfer. While the other one consists of two different disks (diameter = 25 mm) that allows
studying the influence of the heat transfer in different metals. These sections are provided with a
number of temperature sensors included with the unit. To maintain the temperature gradient
constant, a water cooling circuit, whose flow rate can be measured with a sensor, has been
included on one side of the model.
Page 3 of 4
Experimental Procedure
1) Place two of the test sections in the intermediate area
2) Ensure that all the temperature sensors and heating element have been connected
3) Make a water flow circulate through cooling system with SC-2 at 2 l/min
4) Set the voltage of heating resistor to 10W with the power controller
5) Wait until the temperature reading on the sensor becomes stable
6) Repeat the previous steps for different heating powers i-e 15,20,30,50W
7) Exchange the position of test sections and repeat the experiment
8) Use Fourier’s Law, calculate the thermal conductivity by keeping the distance
between temperature sensors is 10mm
Temperature Q (W)
Sensors
T1 35.4
T2 38.5
T3 34.5
T4 30.1
∆T/∆x -78
k 515
T5 35.7
T6 31.1
T7 30
T8 30.7
T9 26.3
T10 25.4
∆T/∆x -151
k 265
Graph
Specimen Calculations
Discussion
Lab Performance (10) Lab Report (10) Viva Voce (10) Signature