Professional Documents
Culture Documents
NON-POLARIZED
1 FORM C RELAY HY RELAYS
12 7.4
FEATURES
.472 .291
• High sensitivity: 150 mW/200 mW
• A wide range of ambient temperature: –40°C to +70°C –40°F to +158°F
10.1
.398 • Sealed construction
• Rating: 1 A 30 V DC
mm inch
SPECIFICATIONS
Contact Characteristics (at 25°C 77°F, 50% Relative humidity)
Arrangement 1 Form C Max. operating speed 20 cpm (at nominal voltage)
Initial contact resistance, max. Initial Between contacts Min. 100 MΩ at 500 V DC
100 mΩ
(By voltage drop 6 V DC 1 A) insulation Between contact and
resistance*1 coil Min. 100 MΩ at 500 V DC
Contact material Gold-clad silver
Nominal switching capacity 1 A 30 V DC Between open
Initial 500 Vrms
Max. switching power 30 W contacts
breakdown
Max. switching voltage 60 V DC voltage*2 Between contacts and
1,000 Vrms
Rating coil
(resistive) Max. switching current 1A
Operate time*3 (at nominal voltage) Max. 5 ms
Max. carrying current 2A
Release time (without diode)*3
Min. switching capacity Max. 4 ms
1 mA, 1 V DC (at nominal voltage)
(Reference value)#1
Temperature rise at nominal voltage
Mechanical (at 180 cpm) 107 Max. 50°C
Expected life Contact carrying current 1 A at 20°C
(min. operations) Electrical (at 20 cpm) Functional*4 Min. 98 m/s2 (10 G)
105
1 A 30 V DC Shock resistance
Destructive*5 Min. 980 m/s2 (100 G)
Coil 58.8 m/s2 {6 G}, 10 to 55 Hz
Functional*6
Nominal operating Standard type 200 mW at double amplitude of 1 mm
Vibration resistance
power High sensitivity type 150 mW 117.6 m/s2 {12 G}, 10 to 55 Hz
Destructive
at double amplitude of 2 mm
Note:
#1 This value can change due to the switching frequency, environmental conditions, Conditions for Ambient –40°C to +70°C
and desired reliability level, therefore it is recommended to check this with the operation, transport temp. –40°F to +158°F
actual load. and storage*7
Remarks (Not freezing and
* Specifications will vary with foreign standards certification ratings. condensing at low Humidity 5 to 85% R.H.
*1 Measurement at same location as “Initial breakdown voltage” section temperature)
*2 Detection current: 10mA
*3 Excluding contact bounce time
Unit weight 1.8 g .063 oz
*4 Half-wave pulse of sine wave: 11ms; detection time: 10µs
*5 Half-wave pulse of sine wave: 6ms
*6 Detection time: 10µs
*7 Refer to 6. Conditions for operation, transport and storage mentioned in
AMBIENT ENVIRONMENT .
TYPICAL APPLICATIONS
• Automotive: Switching to small motor • Low-voltage signal switching and motor • Operating of dish-control motors for
1) Automirrow controller control of small home appliances such PCs and word processors
2)Retractable head light controller as portable video tape recorders and
• Push button device: Dial pulsing audio devices.
DIMENSIONS mm inch
10.1 5.08
.398 .200
0.5
.020 2.54
.100
3.5
.138
2.54
0.5 0.4 dia.
.100
.020 0.25 .016 dia.
5.08 0.25
.200 .010 .010
Schematic (Bottom view)
2.54 7.62
.100 N.C.
.300 (0.82)
(.032)
COM
N.O.
General tolerance: ±0.3 ±.012 Tolerance: ±0.1 ±.004
100
70
50
Life, ×104
Pick-up voltage
1.0 60
30 Max.
20 50
Min.
0.5 10 40
30 Drop-out voltage
100 V AC
resistive load Max.
0.2 20
Min.
10
0.1 0
10 30 60 100 300 0.2 0.4 0.6 0.8 1.0 1.2 1.4 10 100 1,000 2,000
Contact voltage, V Switching current, A No. of operations, ×104
4. Electrical life
Tested sample: HY1-12V, 6 pcs.
Condition: 1 A 30 V DC resistive load, 30 cpm Change of pick-up and drop-out voltage Change of contact resistance
100
Ratio against the rated voltage, %V
90
Contact resistance, mΩ
80 Pick-up voltage 80
Circuit:
70 Max.
60 60 Max.
50 Min.
40 Drop-out voltage 40
Max. Min.
30
20 Min. 20
N.C. side: 3 pcs.
10
N.O. side: 3 pcs.
0 0
10 20 10 20
No. of operations, ×10
4 No. of operations, × 104
5-(1). Coil temperature rise 5-(2). Coil temperature rise 6. Operate/release time characteristics
(150 mW high sensitivity type) (200 mW Standard type) Tested sample: HY1Z-12V, 5 pcs.
Tested sample: HY1-9V, 5 pcs. Tested sample: HY1Z-12V, 5 pcs. Ambient temperature: 25°C 77°F
Ambient temperature:24°C 75°F Ambient temperature: 23°C 74°F
100 100 3
90 90
Coil temperature rise, °C
Operate/release time, ms
80 80
1A Operate time
70 1A 70
2
60 60
0A
50 0A 50
Max.
40 40 x
1 Min.
30 30 Release time
Max.
x
20 20 Min.
10 10
0 0 0
80 100 120 140 160 180 80 100 120 140 160 180 80 100 120
Coil applied voltage, %V Coil applied voltage, %V Coil applied voltage, %V
7. Distribution of pick-up and drop-out voltages 8. Distribution of contact resistance 9. Malfunction shock
Tested sample: HY1-12V, 50 pcs. Tested sample: HY1-12V, 50 pcs. Tested sample: HY1Z-12V, 6 pcs.
Ambient temperature: 23°C 74°F N.C. side N.O. side
30 30
Deenergized condition
N.C. side Z X X’ Y Energized condition
N.O. side Z’ 980m/s 2
25 Drop-out voltage 25 Y
Y’
980m/s 2
X Z
20 20
980m/s 2
Quantity
Quantity
Pick-up voltage
15 15
10 10 980m/s 2 980m/s 2
Z’ X’
5 5
980m/s 2
Y’
0 0
10 20 30 40 50 60 70 80 90 100 30 40
Pick-up/drop-out voltage, V Contact resistance mΩ