Professional Documents
Culture Documents
Pantalla anterior
Bienvenido: pvaldez
Producto: MO TO R GR ADER
Mode lo: 120H MO TO R GR ADER C AF
C onfiguración: 120H Motor Grade r C AF00001-UP (MAC HINE)
PO W ER ED BY 3126B Engine
i03525680
Illustration 1 g01775062
Schematic of the solenoid valve (No. 2)
This diagnostic code is recorded when the voltage of the solenoid circuit is above normal.
System Response:
When this diagnostic code is active, the ECM will turn off current to the failed solenoid. Only gears that use this solenoid
will be allowed to operate by the power train ECM.
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&calledpage=/sisweb/sis… 1/3
15/8/2020 120H Motor Grader CAF00001-UP (MACHINE) POWERED BY 3126B Engine(SEBP3617 - 68) - Documentación
Test Step 1. CHECK THE SIGNAL CIRCUIT FOR A SHORT TO THE +BATTERY CIRCUIT.
A. Turn the disconnect switch and the key start switch to the OFF position.
D. At machine harness connector J1, measure the resistance from contact J1-17 (solenoid signal) to all possible
sources of positive voltage.
Expected Result:
Results:
OK - Each resistance is greater than 5000 ohms. The machine harness is correct. Proceed to Test Step 2.
Repair: There is a short in the machine harness. The short is between J1-17 (754-BU) and the circuit that has a
low resistance measurement. Repair the machine harness or replace the machine harness.
STOP
F. Stop the machine and place the parking brake switch in the OFF position.
Expected Result:
Results:
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&calledpage=/sisweb/sis… 2/3
15/8/2020 120H Motor Grader CAF00001-UP (MACHINE) POWERED BY 3126B Engine(SEBP3617 - 68) - Documentación
Repair: The problem has not been corrected. It is unlikely that the ECM has failed. Perform the previous Steps
again. If the cause of the diagnostic code is not found, replace the power train ECM. See the Troubleshooting,
"Electronic Control Module (ECM) - Replace" Story in this manual for additional information.
STOP
Repair: The problem does not exist at this time. Resume normal machine operation.
STOP
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&calledpage=/sisweb/sis… 3/3