Professional Documents
Culture Documents
MT Level - I QB 2 PDF
MT Level - I QB 2 PDF
MT LEVEL I QB - 2
10. The ability of a material to emit visible light while being irradiated
by UV light is called
a. Fluorescence
b. phosphorescence
c. iridescence
d. Birefringence
13. When a part is magnetized such that the flux lines run essentially
parallel to the long axis of the part it is called
a. parallel magnetization
b. circular magnetization
c. longitudinal magnetization
d. a long shot
21. In the left hand rule as applied to a solenoid, the fingers point in
the direction of
a. north
b. south
c. current flow
d. force on the conductor
22. In the left hand rule, as it applies to a solenoid, the thumb point in
the direction of
a. North
b. South
c. current flow
d. force on the conductor
23. The relative amount of flux linkage between two coils (as in a
transformer) is called
a. mutual inductance
b. figure of merit
c. coupling coefficient
d. flux factor
26. As one increases the size of the MPI test system from small yokes
and portable units to large bench units the single most significant
difference is
a. length of piece that can be tested
b. the ability to use liquid suspensions in the big units
c. the amount of magnetizing current available
d. type of magnetic field that can be generated
36. For best demagnetization results using a coil with A.C. and
passing parts through it you should
a. pass the part through with its long axis parallel to the coil axis
b. hold the part close to the coil
c. both a and b
d. switch the current on only when the part is centred along its length
in the coil
38. For rings and hollow parts a handy means of A.C. demagnetization
is
a. using a yoke
b. a central conductor using decreasing current
c. surge pulses through prod contacts
d. swinging field technique
39. The most likely tool you would use to determine if a part has been
adequately demagnetized is the
a. Hall detector
b. field meter
c. electrogram
d. magnetometer
MT LEVEL I QB 2 – ANSWERS