You are on page 1of 3

Published: 28-Apr-2011

General Information - Diagnostic Trouble Code (DTC) IndexDTC: Audio


Front Control Module (ACM)
Description and Operation

• NOTE: If a control module or component is suspect and the vehicle remains under manufacturer warranty, refer to the
Warranty Policy and Procedures manual (section B1.2), or determine if any prior approval program is in operation, before
the replacement of a component.

• NOTE: Generic scan tools may not read the codes listed, or may read only 5-digit codes. Match the 5 digits from the scan
tool to the first 5 digits of the 7-digit code listed to identify the fault (the last 2 digits give extra information read by the
manufacturer-approved diagnostic system).

• NOTE: When performing voltage or resistance tests, always use a digital multimeter (DMM) accurate to three decimal
places, and with an up-to-date calibration certificate. W hen testing resistance always take the resistance of the DMM
leads into account.

• NOTE: Check and rectify basic faults before beginning diagnostic routines involving pinpoint tests.

• NOTE: Inspect connectors for signs of water ingress, and pins for damage and/or corrosion.

• NOTE: If DTCs are recorded and, after performing the pinpoint tests, a fault is not present, an intermittent concern may
be the cause. Always check for loose connections and corroded terminals.

Description And Operation

For a detailed description of the audio front control system, refer to the relevant Description and Operation section in the
workshop manual.
For additional information, refer to: Audio System (415-01 Information and Entertainment System, Description and
Operation).

Audio Front Control Module (ACM)


DTC Description Possible Cause Action
B1134-11 Phone input Phone input circuit - short Refer to electrical circuit diagrams and check phone input
to ground circuit for short to ground

B1134-12 Phone input Phone input circuit - short Refer to electrical circuit diagrams and check phone input
to power circuit for short to power

B1134-13 Phone input Phone input circuit - open Refer to electrical circuit diagrams and check phone input
circuit circuit for open circuit

B1A01-11 Speaker #1 Left front speaker circuit - Refer to electrical circuit diagrams and check left front
short to ground speaker circuit for short to ground

B1A01-12 Speaker #1 Left front speaker circuit - Refer to electrical circuit diagrams and check left front
short to power speaker circuit for short to power

B1A01-1A Speaker #1 Left front speaker circuit - Carry out pinpoint tests associated with this DTC using the
resistance below threshold manufacturer approved diagnostic system

B1A01-1B Speaker #1 Left front speaker circuit - Carry out pinpoint tests associated with this DTC using the
resistance above threshold manufacturer approved diagnostic system

B1A01-1C Speaker #1 Left front speaker circuit - Carry out pinpoint tests associated with this DTC using the
voltage out of range manufacturer approved diagnostic system

B1A02-11 Speaker #2 Right front speaker circuit - Refer to electrical circuit diagrams and check right front
short to ground speaker circuit for short to ground

B1A02-12 Speaker #2 Right front speaker circuit - Refer to electrical circuit diagrams and check right front
short to power speaker circuit for short to power

B1A02-1A Speaker #2 Right front speaker circuit - Carry out pinpoint tests associated with this DTC using the
resistance below threshold manufacturer approved diagnostic system

B1A02-1B Speaker #2 Right front speaker circuit - Carry out pinpoint tests associated with this DTC using the
resistance above threshold manufacturer approved diagnostic system

B1A02-1C Speaker #2 Right front speaker circuit - Carry out pinpoint tests associated with this DTC using the
voltage out of range manufacturer approved diagnostic system

B1A03-11 Speaker #3 Left rear speaker circuit - Refer to electrical circuit diagrams and check left rear
short to ground speaker circuit for short to ground

B1A03-12 Speaker #3 Left rear speaker circuit - Refer to electrical circuit diagrams and check left rear
short to power speaker circuit for short to power

B1A03-1A Speaker #3 Left rear speaker circuit - Carry out pinpoint tests associated with this DTC using the
resistance below threshold manufacturer approved diagnostic system

B1A03-1B Speaker #3 Left rear speaker circuit - Carry out pinpoint tests associated with this DTC using the
resistance above threshold manufacturer approved diagnostic system
DTC Description Possible Cause Action
B1A03-1C Speaker #3 Left rear speaker circuit - Carry out pinpoint tests associated with this DTC using the
voltage out of range manufacturer approved diagnostic system

B1A04-11 Speaker #4 Right rear speaker circuit - Refer to electrical circuit diagrams and check right rear
short to ground speaker circuit for short to ground

B1A04-12 Speaker #4 Right rear speaker circuit - Refer to electrical circuit diagrams and check right rear
short to power speaker circuit for short to power

B1A04-1A Speaker #4 Right rear speaker circuit - Carry out pinpoint tests associated with this DTC using the
resistance below threshold manufacturer approved diagnostic system

B1A04-1B Speaker #4 Right rear speaker circuit - Carry out pinpoint tests associated with this DTC using the
resistance above threshold manufacturer approved diagnostic system

B1A04-1C Speaker #4 Right front speaker circuit - Carry out pinpoint tests associated with this DTC using the
voltage out of range manufacturer approved diagnostic system

B1A56-13 Antenna Antenna circuit - open Refer to electrical circuit diagrams and check antenna circuit
circuit for open circuit

B1B69-11 Antenna 12 Antenna 12 volt supply Refer to electrical circuit diagrams and check antenna 12 volt
volt supply circuit - short to ground supply circuit for short to ground
circuit
B1B69-15 Antenna 12 Antenna 12 volt supply Refer to electrical circuit diagrams and check antenna 12 volt
volt supply circuit - short to power, supply circuit for short to power, open circuit
circuit open circuit

B1D19-16 Compact disc Circuit voltage below Install a new integrated audio module, refer to the new
unit threshold module/component installation note at the top of the DTC
Index.
For additional information, refer to: Audio Unit (415-01
Information and Entertainment System, Removal and
Installation).
B1D19-77 Compact disc Commanded position not Install a new integrated audio module, refer to the new
unit reachable module/component installation note at the top of the DTC
Index.
For additional information, refer to: Audio Unit (415-01
Information and Entertainment System, Removal and
Installation).
B1D19-93 Compact disc No operation Install a new integrated audio module, refer to the new
unit module/component installation note at the top of the DTC
Index.
For additional information, refer to: Audio Unit (415-01
Information and Entertainment System, Removal and
Installation).
B1D78-11 Auxiliary input Auxiliary input circuit - short Refer to electrical circuit diagrams and check auxiliary input
to ground circuit for short to ground

B1D78-12 Auxiliary input Auxiliary input circuit - short Refer to electrical circuit diagrams and check auxiliary input
to power circuit for short to power

B1D78-13 Auxiliary input Auxiliary input circuit - open Refer to electrical circuit diagrams and check auxiliary input
circuit circuit for open circuit

B1D79-11 Microphone Microphone input circuit - Refer to electrical circuit diagrams and check microphone
input short to ground input circuit for short to ground

B1D79-12 Microphone Microphone input circuit - Refer to electrical circuit diagrams and check microphone
input short to power input circuit for short to power

B1D79-13 Microphone Microphone input circuit - Refer to electrical circuit diagrams and check microphone
input open circuit input circuit for open circuit

U3000-49 Control module Internal electronic failure Install a new control module, refer to the new
module/component installation note at the top of the DTC
Index.
For additional information, refer to: Audio Unit (415-01
Information and Entertainment System, Removal and
Installation).
U3000-55 Control module Incorrect car configuration Check/up-date Car Configuration File using manufacturer
data received approved diagnostic system

U3000-87 Control module Missing message Check CJB for DTCs and refer to DTC Index.
For additional information, refer to: Communications Network
(418-00 Module Communications Network, Diagnosis and
Testing).
Check information and entertainment module for Car
Configuration File and MOST network DTCs and refer to
relevant DTC Index. Carry out MOST/CAN network tests using
the manufacturer approved diagnostic system
DTC Description Possible Cause Action
U3000-98 Control module Component or system over Check for additional DTCs and refer to relevant DTC Index,
temperature check/monitor system for re-occurrence

U3003-62 Battery voltage Mis-match in voltage, of 2 Carry out pinpoint tests associated with this DTC using the
volts or more, between manufacturer approved diagnostic system
integrated control module
and CJB

You might also like