Professional Documents
Culture Documents
72-01-50
Engine Model(s): MODEL(S)PW127G (BUILD SPEC. 945/1316/1436)
2. Consumable Materials
The consumable materials listed below are referred to in this section. For more data, refer to the
CONSUMABLE MATERIALS section at the beginning of this manual.
WARNING: READ THE MATERIAL SAFETY DATA SHEETS BEFORE YOU USE THESE
MATERIALS. SOME MATERIALS CAN BE DANGEROUS.
3. Special Tools
Not Applicable
4. Fixtures, Equipment and Supplier Tools
Not Applicable
5. Pressure Oil Filter (Ref. Fig. 301)
Figure 301 Pressure Oil Filter - Removal/Installation
c37181
1. Plug
2. Packing
3. Nut
4. Washer
5. Bracket
6. Cover
7. Packing
8. Retaining Ring
9. Filter
10. Packing
11. Retaining Ring
12. Screen
A. Removal
(1) Remove the oil temperature probe (Ref.
AMM).
(2) Remove plug (1) and drain oil into a container. Discard packing
(2).
(3) Remove nuts (3), washers (4), bracket (5), cover (6) and packing (7). Discard
packing.
(4) Remove retaining ring (8) and filter (9) from cover (6). Discard packing
(10).
(5) Inspect oil filter (Ref.
INSPECTION/CHECK).
(6) Remove retaining ring (11) and screen (12).
NOTE: Screen is recommended to be removed and cleaned only when the associated oil
filter is replaced.
B. Installation
(1) Install screen (12) (concave face outward) and secure with retaining ring
(11).
icn-00198-g000009477-001-01
1. Nut
2. Washer
3. Bracket
4. Cover
5. Packing
6. Retaining Ring
7. Filter
8. Spacer Ring ( Pre-SB21866)
9. Packing
10 . Spacer Ring ( Post-SB21866)
A. Removal
(1) Remove nuts (1), washers (2), bracket (3), cover (4) and packing (5). Discard
packing.
(2) Pre-SB21866: Remove the retaining ring (6), the filter (7) and the spacer ring (8) from
the cover (4).
(3) Post-SB21866: Remove the retaining ring (6), the filter (7) and the spacer ring (10) from
the cover (4).
(4) Remove packing (9) from filter. Discard
packing.
(5) Inspect oil filter (Ref.
INSPECTION/CHECK).
B. Installation
(1) Lubricate packing (9) with engine oil (PWC03-001) and install on filter
(7).
(2) Pre-SB21866: Install the spacer ring (8) and the filter (7) in the cover (4), then attach
with the retaining ring (6).
(3) Post-SB21866: Install the spacer ring (10) and the filter (7) in the cover (4), then attach
with the retaining ring (6).
(4) Lubricate packing (5) with engine oil (PWC03-001) and install on
cover.
(5) Install cover (4), washers (2), bracket (3), and nuts (1). Torque nuts 32 to 36 lb.in. (3.62-
4.07 Nm).
(6) Carry out a leak check (Ref.
Adjustment/Test).