Professional Documents
Culture Documents
Search
Primary Menu
Skip to content
For larger size pipes and where pressure drop in elbow is not critical, miters can be used instead of
standards elbows.
In the figure above, dotted lines are where the pipe should be cut. Each dotted cut line has a vertical
reference line marked at following distances from pipe end.
3. Cut Back : Offset distance of cut lines from reference lines at the top and bottom of pipe.
Where :
1. D : Required elbow degrees.
2. N : Numer of cuts.
L1 = 151.6 mm
L2 = 75.8 mm
Cutback = 27.15 mm