Professional Documents
Culture Documents
provides protection to the flight crew in event of smoke and other harmful gases.
A. Rechargeable
B. No rechargeable
Correct
A. Rechargeable cylinder
B. Supplemental chemically generated
Correct
3) The PBE provides the crew with __________________ oxygen for respiratory and visual
protection against the effects of smoke and other harmful gases.
A. Positive pressure
B. On demand
Correct
5) A difference in pressure indication between the MFD and the oxygen pressure gauge outside
the airplane may be observed. The difference occurs due to a ____________ correction in the
MFD that does not occur on the oxygen pressure gauge.
A. Pressure
B. Temperature
Correct
A. 1850 psi
B. 2000 psi
Incorrect
7) When the oxygen mask stowage box is closed and the TEST/RESET switch is pressed the
headset boom microphone is restored and the mask's microphone is ...
A. Turned on.
B. Turned off.
Discuss this Question
Correct
A. Normal Mode provides supplemental oxygen diluted with cabin air according to the
cabin pressure altitude until a preset point where the user inhales 100% oxygen.
B. 100% Mode provides non-diluted oxygen to the crew regardless of cabin altitude.
C. The “EMER” setting provides non-diluted oxygen regardless of cabin altitude, with a
slightly positive pressure.
Incorrect
A. Normal Mode provides supplemental oxygen diluted with cabin air according to the
cabin pressure altitude until a preset point where the user inhales 100% oxygen.
B. 100% Mode provides non-diluted oxygen to the crew regardless of cabin altitude.
C. The “EMER” setting provides non-diluted oxygen regardless of cabin altitude, with a
slightly positive pressure.
Discuss this Question
Correct
A. Normal Mode provides supplemental oxygen diluted with cabin air according to the
cabin pressure altitude until a preset point where the user inhales 100% oxygen.
B. 100% Mode provides non-diluted oxygen to the crew regardless of cabin altitude.
C. The “EMER” setting provides non-diluted oxygen regardless of cabin altitude, with a
slightly positive pressure.
Correct
11) The PBE unit is for emergency use only. It is vacuum-sealed in a small bag inside a box. The
box is equipped with a green "good condition indicator". The equipment hood isolates the
user's head from the external ambient gases by means of an elastic neck seal. Oxygen flow
starts automatically after hood donning and will be supplied for at least ______ .
A. 15 min
B. 45 min
Incorrect
12) The PBE unit provides the crew with positive pressure oxygen for respiratory and visual
protection against the effects of smoke and other harmful gases at altitudes up to _________.
A. 35000 ft
B. 25000 ft
Discuss this Question
Correct
13) Individual chemical oxygen generators supply the passenger oxygen system during an
emergency descent in the event of cabin depressurization. The passenger oxygen system
provides supplemental oxygen only to the following:
14) Passenger oxygen masks are located in the PSUs above the passenger seats.
Each PSU contains either two or three masks that supply oxygen only for approximately ...
15) The supplemental oxygen is ________ with ambient air according to the cabin altitude. At
higher cabin altitudes, the mask provides 100% supplemental oxygen.
A. Diluted
B. Not diluted
Correct
17) The masks are automatically deployed when the cabin altitude is between ...
A. 14000 ft to 14750 ft.
B. 15000 ft to 15750 ft.
Correct
18) Manual deployment can be performed from the cockpit by positioning the passenger oxygen
selector knob to the ______ position. A manual release tool located near each flight attendant
station can be used in case dispensing unit door fails.
A. ON
B. OVRD
Correct
19) When the passenger mask doors are automatic or manual commanded open
the ____________________ turns ON the FASTEN SEAT BELT and the NO SMOKING (NO
ELEC DEVICE optional) regardless of the switch position.
A. Pilot manually
B. System automatically
Incorrect
20) The switch normal operation is inhibited until the MASKS DEPLOY switch is set to ____ position.
A. OFF
B. OVRD
Discuss this Question
Incorrect
21) The portable oxygen cylinders are for flight attendants use to assist passengers in case of
sudden cabin decompression or for first aid purposes. The cylinders store 312 • (11 ft3) of
oxygen, pressurized to _________. at 21°/70°F.
A. 1800 psi
B. 2000 psi
Discuss this Question
Correct
A. One regulates flow at 2 lt per minute for walk-around use and the second provides flow at
4 lt per minute for first aid use.
B. One regulates flow at 6 lt per minute for walk-around use and the second provides flow at
8 lt per minute for first aid use.