HG-200 GENERAL MATERIAL production unless so stated in the Specification, and
REQUIREMENTS as long as the product complies with the requirements of the Specification. HG-200.1 Materials Subject to Pressure Stress. Material subject to stress due to pressure shall conform HG-200.6 Materials With Thicknesses Exceeding to one of the specifications given in Section II and Specification Limits. Materials having thicknesses out- shall be limited to those that are permitted in HF-200 side of the limits given in the title or scope clause of for boilers of wrought materials and HC-200 for cast a specification in Section II may be used in construction, iron boilers. provided they comply with the other requirements of the Specification and with all thickness requirements HG-200.2 Internal Parts Subject to Deterioration. of this Code. Materials shall not be used for internal parts which are liable to fail due to deterioration when subjected to HG-200.7 Nonpressure Part Materials. Material saturated steam temperatures at or below the maximum for nonpressure parts, such as skirts, supports, baffles, allowable working pressure. lugs, clips, and extended heat-transfer surfaces, need not conform to the specifications for the material to HG-200.3 Materials Not Found in Section II. Mate- which they are attached or to a material specification rial not covered by specifications in Section II shall permitted in HF-200 or HC-200; but, if welded, they not be used unless authorization to use the material is shall be of weldable quality. The allowable stress value granted by the Boiler and Pressure Vessel Committee shall not exceed 80% of the maximum allowable stress on the basis of data submitted to the Committee in permitted for similar material in Tables HF-300.1 and accordance with Appendix A. HF-300.2. Satisfactory performance of a specimen in such service shall not make the material acceptable for HG-200.4 Materials Use Not Limited by Speci- use in pressure parts of a vessel. fication Title. The title or scope paragraph of a material specification in Section II as respects product form or service shall not limit the use of a material, provided HG-201 SPECIFIC MATERIAL the material is suitable for the application and its use REQUIREMENTS is permitted by the rules of this Section. Specific material requirements for assemblies con- HG-200.5 Materials Use Not Limited by Method structed of wrought materials are given in Part HF, of Production. Materials covered by specifications in Article 2 and for assemblies constructed of cast iron Section II are not restricted as to the method of in Part HC, Article 2.
COPYRIGHT American Society of Mechanical Engineers