Professional Documents
Culture Documents
Guia Manual Inspection Manteniemiento Part Catalog Piper
Guia Manual Inspection Manteniemiento Part Catalog Piper
2013-01-30
CCI – 025
Rev: 01
In the Service Manual and Parts Catallog of PA28, found the following information:
3- What is a Section of Removal and Disassembly of Main Wheel, and describe 2 steps; and
what is the P/N the item 18:
4- Describe what method of inspection is applied in this procedure: Removal and Disassembly of
Main Wheel:
P8 / 2020
RTA: Section 4 (IV) VIII-V
6- In Section 8.8 what is the correct procedure of torque the bolts, and the torque value:
RTA: Install and tighten each propeller bolt, with washer, finger tight. Use a torque wrench for
final tightening and tighten in sequence so that all bolts are pulled down evenly. Torque three-
eights inch bolts to 280 to 300 inch-pounds or one-half inch bolts to 720 to 780 inch-pounds
(60 to 65 foot-pounds).
a- Inspections Of Magneto
P8 / 2020
12- Discrepancy: During walk around was found the Main wheel with visible canvas
Action Taken:
a- Section of Manual for removal and installation.? RTA: Section VII
b- What is the value for the torque wheel nuts? RTA: Torque wheel nuts to 150-inch pounds
c- What is the Section of manual for bleed the brakes? RTA: Section VII
d- What is the P/N of the Main Wheel Assembly? RTA: P/N 451. 769
13- Discrepancy: During Pre-flight inspection the the Lh Wing Flap control was found whit several
dent damage:
a- Section of Manual for removal and installation?
b- During Install procedure describe the item (b) and (c).
(b) __________
(c) __________
P8 / 2020