Professional Documents
Culture Documents
CRETE PM
DESCRIPTION
Ultrachem®Crete PM is mortar (semen + sand) that l The surface’s moisture should be kept high.
has been modified to facilitate repairing of concrete Water should be poured on sprayed on for
or grouting vertical areas without using formwork. 5 – 10 minutes continuously.
It resists shrinkage, is thick, sticky and has high l The edges and tips of repaired areas should be
pressure strength. It is applied to vertical areas like cut to make a right angle from the vertical line.
walls and ceilings by patching and smoothing with
trowels. It is used to repair spongy and shedding II. MIXING
concrete in vertical structure that are caused from l Ultrachem ® Crete PM is to be mixed in a pail
TECHNICAL DATA
Age Compressive strength
3 days 265 kg/cm²
7 days 387 kg/cm² l Ultrachem ® Crete PM is applied by using a
28 days 445 kg/cm² wooden trowel of steel trowel.
Volume changing + 0.2 % l It is not recommended to apply Ultrachem®
Setting time 4.07' Crete PM all at once in a single thick coat. It
Note : The technical data based on 240 gram water usage for 1 kg would be better to apply it partially in 2-3 coats.
Ultrachem®Crete PM. Each coat should be pressed manually by hand
or mechanically until solid and sticky to the
APPLICATION substrate.
I . SURFACE REQUIREMENTS l Interval between each coat should be less than
l The surface should be clean especially from dirt 1 hour.
caused by oil or curing compounds. l At the end of last coat, use a steel trowel to level
l The surface should be rough. Use hammer and the surface of the coat. Usually, it takes several
chisel for chipping. For wider areas, sand blasting attempts at leveling or 10-15 minutes.
or water jetting method may be used. l Special rulers or beams could be used for the leveling
process. It should be done before initial application
of Ultrachem®Crete PM .
CRETE PM
Filling Mortar Applied To Vertical Area and Ceiling
IV . CURING
Approximately 6-7 hours after application, Ultrachem®
Crete PM will begin drying. It should be covered
with plastic or be sprayed with a liquid curing
compound immediately (Ultrachem®Cure WB) to
stop water loss caused by evaporation.
PACKAGING
Ultrachem®Crete PM is packed in 25 kg plastic
bags.
STORAGE
Ultrachem®Crete PM has a shelf life of at least 12
months, provided it is stored unopened in a cool,
and dry location.