Professional Documents
Culture Documents
Ingredients Equipment
1 Gallon of Milk (not Good Thermometer
ultra-pasteurized)
Knife to Cut Curds
1 Pack C21 Buttermilk
Culture or 1/4 tsp Spoon or ladle to Stir
MA4002 (no culture for Curds
raw milk) Large Colander
1/4 tsp Single 1 M222 Basket Cheese
Strength Liquid Rennet Mold
(1/8 tsp for raw milk)
Draining Mat
1/2 oz Salt
Dried mint (optional)
3/8 tsp Calcium
Chloride for
Pasteurized Milk
1/8 tsp Citric Acid (for
Whey Ricotta)
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 1/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
1 Heat Milk
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 2/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
Now add about 1/4 tsp. of single strength liquid rennet diluted in
1/4 cup of water.
Total coagulation time is 30-40 minutes but you will begin to notice
the milk beginning to thicken in 15-20 minutes. Since there is little
to no ripening time and acid development for this cheese, more
rennet than normal is being used.
It is OK if the temp drops a few degrees during this time.
As with most cheeses, a firm curd is essential to the rest of the
cheese making process. In the photos above a long knife is used to
start the break and then slowly lifted to see the curd split naturally.
What you are looking for here is a nice smooth split. No small pieces
should be evident. The whey should not show as too clear (cutting
too late) or too cloudy or droopy (cutting too early). The last photo
shows what the fresh break should look like. Always look at the
fresh whey collecting in this fresh break.
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 3/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
3 Cut Curds
The curd can now be cut to .75-1.5 inch squares in a vertical manner.
Allow it to rest 3-5 minutes to heal and then using a long spoon or
ladle, cut horizontally into even sized cubes.
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 4/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 5/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
The dry curds can now be transferred to their form for draining. A
light hand pressure will help the consolidation of curd and, if making
more than 1 form, they can be stacked and reversed for a little
weight.
While the whey is heating, the curds may continue to rest with a
little weight. Either stacking of the forms or a 1-2 lb. weight for a
single cheese will do.
Make sure you turn them at 15-20 minute intervals to form a well
consolidated cheese.
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 6/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
6 Bonus: Anari/Ricotta
It's easy to make Anari/Ricotta from the whey, just follow the steps
below.
The whey should be stirred gently while it heats. Once the
temperature increases to 150°F, add 1/8 tsp of citric acid per gallon
of milk to the whey. This will increase the yield of Anari/Ricotta.
When the temperature reaches 165-170°F add about 1 tsp of salt
and a pint of milk to the whey. The milk will increase the richness of
the Anari/Ricotta you skim off.
As the whey reaches 185-195°F, stop stirring and allow the Ricotta
to rise to the top for about 10 min. This curds can then be skimmed
off into small cheese mold to drain.
Now you will have a nice batch of Ricotta along with a clear whey
that can be used to heat the Halloumi.
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 7/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
After heating the whey and making Ricotta, the cheese should be
well formed into nice rounds about 1.5-2 inches thick as you see in
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 8/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 9/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
As the cheese cools and while it is still warm, I flatten with a slight
hand pressure to form a larger and flatter disc of cheese.
To finish the cheese sprinkle with:
Salt - about 1/2 oz. of cheese salt sprinkled over one side of the
cheese disc. .. this equates to only about 3% salt addition but
traditionally up to 5% and more would be added for
preservation in the hot Mediterranean climate.
Mint - enough mint to cover the cheese surface. This is
traditionally dried but I see no reason not to use fresh if the
cheese will be consumed fresh or even if you are adding other
herbs to taste.
The cheese can then be folded into a crescent and pressed slightly
as it cools
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 10/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
At this point you will have your finished cheese and after 3-5 days, it
is ready to be used. It should be kept refrigerated due to the lighter
salting I have applied here or if you are looking for a more
traditional "Mediterranean Style" cheese with higher salt, then
increase the salt to about 5%. The higher salt will keep well at room
temperature for several days.
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 11/12
9/20/2020 Halloumi Recipe | Cheese Maker Recipes | Cheese Making Supply
To use the cheese, our favorite way is to "GRILL" the cheese and
caramelize the surface for a really rich flavor with a soft and warm
interior. The cheese will take a very high heat without melting and
will acquire a wonderful texture and flavor. It will withstand several
minutes on each side. This can be done on the outdoor grill or in a
pan on the stove.
You can also use this cheese by stuffing with other wonderful things
such as peppers and grilled vegetables or cut into cubes and used in
kababs etc as well as cold in salads.
Another more traditional method of storing is to pack cheeses
tightly in covered jars or containers, and cover with 8 to 12 percent
brine. They can then be aged for a few weeks up to several months.
These cheeses will be rather high in salt but can be used much like
Feta in dishes that would normally be salted (but just omit the salt).
https://cheesemaking.com/collections/recipes/products/halloumi-cheese-making-recipe 12/12