Professional Documents
Culture Documents
Kinetic Characteristics of Functional Bacteria in IFAS Process For Partial Nitrification PDF
Kinetic Characteristics of Functional Bacteria in IFAS Process For Partial Nitrification PDF
IFAS 工艺短程硝化过程中功能菌的动力学特性
Kinetic characteristics of functional bacteria in IFAS process for partial nitrification. ZHANG Kai, LI Jun*, LIANG Dong-bo,
HOU Lian-gang, ZHANG Jing, WANG Xiu-jie (The College of Architecture and Civil Engineering, Beijing University of
Technology, National Engineering Laboratory of Urban Sewage Advanced Treatment and Resource Utilization Technology, Beijing
100124, China). China Environmental Science, 2020,40(4):1507~1514
Abstract:The kinetic characteristics of aerobic ammonia oxidizing bacteria (AOB) and nitrite oxidizing bacteria (NOB) under
different influent NH4+-N loading and free ammonia (FA) concentration were studied by biofilm-activated sludge composite process
(IFAS). The contributions of different microbial aggregates (suspended sludge and attached biofilm) to the removal of NH4+-N were
investigated, and the biological adsorption and biodegradation were analyzed quantitatively. The amount and spatial distribution of
total bacteria, AOB, and NOB were observed by fluorescence in situ hybridization (FISH). The experimental results showed that with
the increased of influent NH4+-N concentration, the effluent NO3--N concentration decreased and the NO2--N accumulated a lot.
When the influent NH4+-N concentration was 480mg/L, the NH4+-N removal rate and the nitrite accumulation rate (NAR) were
stable above 95% and 80%, respectively, while the FA increased from (2.77 ±0.07) mg/L to (16.35 ±0.3) mg/L, and the NAR
increased from 9.42% to 83.31%, which achieved the inhibition of NOB. In the process of NH4+-N removal, biossorption and
microbial degradation accounted for 3.4% and 88.1% of NH4+-N removal, respectively. The ratio of AOB in suspended sludge and
biofilm increased from 27.4% and 10.3% to 41.3% and 18.1%, respectively, indicating that suspended sludge was more beneficial to
enrichment of AOB than biofilm.
Key words:partial nitrification;IFAS;inhibition kinetic;adsorption
短程硝化(PN)被认为是传统硝化反硝化脱氮工 酸盐氮的积累[8],因此,研究者在抑制亚硝酸盐氧化
艺最有前景的替代方法[1],短程硝化是指将氨氮氧化 细菌(NOB)活性和强化氨氧化细菌(AOB)活性方面
成亚硝酸盐氮,避免进一步氧化成硝酸盐氮的过程. 做了大量的研究,主要包括:温度、pH 值、溶解氧
(DO)、游离氨(FA)等[9
- 13]
基于短程硝化的新型生物脱氮技术包括限氧自养硝 .研究表明[14]当温度高于
化-反硝化脱氮工艺(OLAND)[2]、部分亚硝化厌氧氨 25℃时,AOB 的增长速率高于 NOB 的增长速率;而
[3]
氧化脱氮工艺(SHARON- ANAMMOXA) 、全程自 当温度低于 25℃时,FA 和游离亚硝酸(FNA)浓度则
[4]
养脱氮工艺(CANON) 、同步亚硝化厌氧氨氧化耦 成为抑制 NOB 活性的最主要的方式[15],当 FA 浓度
合反硝化工艺(SNAD)[5],这些新型生物脱氮工艺可 收稿日期:2019-09-09
[6] 基金项目:国家水体污染控制与治理科技重大专项(2017ZX07103-001);
以节省 25%的氧气 ,与厌氧氨氧化工艺相结合时可
北京工业大学研究生科技基金(基于 IFAS-EGSB 的厌氧氨氧耦合反硝
以节省 100%的外加碳源[7]. 化工艺及菌群特性研究-ykj-2018-00400)
实现短程硝化的关键是能够得到稳定的亚硝 * 责任作者, 教授, 18811069614@163.com
1508 中 国 环 境 科 学 40 卷
1 材料与方法
NO3 -N 的浓度.NH4+-N 的比去除率为单位生物量
-
硝化过程的反应器,由有机玻璃制成,在圆柱形反应 -
(NO2 -N mg/(h·g)).
器外侧套有 20mm 水浴套筒,反应器内径 100mm,反 1.3.3 计算方法[22 25]
-
(1)微生物的吸附量定义为
应器高度 400mm,有效容积约为 3.3L,采用聚氨酯海 批试实验中,在反应进行的前 5min 内 NH4+-N 的去
绵填料作为生物膜的载体,体积填充比约为 25%.反 除量;(2)载体填料生物量浓度的测定方法:从反应器
应器具体运行条件见表 1. 的上、中、下分别随机选取 2 个载体填料,从载体填
1.2 实验用水及接种污泥 料上提取生物膜,在 105℃烘干称重,计算平均载体
实验用水采用人工合成污水,主要成分含有 上生物膜干重.
NH4Cl、乙酸钠、NaHCO3、KH2PO4、MgSO4·7H2O、 (3)Halande 动力学公式模型:
CaCl2·2H2O、FeSO4;接种污泥取自北京高碑店污水 rmax S
r= (1)
处理厂中曝气池的硝化污泥,接种污泥的污泥体积 S2
Ks + S +
指 数 (SVI) 值 (95.6 ± 5.5), 污 泥 浓 度 (MLSS) 为 Ki
4期 张 凯等:IFAS 工艺短程硝化过程中功能菌的动力学特性 1509
FA = × [ ⎣ ⎦
T )]
(2)
14 e 6344 /( 273 +
+ 10 pH
浓度的增加出现增加的趋势,但是反应器内 NOB 活
+
式中:FA 为游离氨浓度,mg/L;ρ[NH 4
+
-N] 为 NH4 -N 浓 性依然较高,系统内仍然以全程硝化为主;阶段Ⅲ,继
度,mg/L;T 为温度,℃. 续 增 加 进 水 NH4+-N 浓 度 至 240mg/L, 此 阶 段
1.3.4 荧光原位杂交分析(FISH) 采用 FISH 技术 NH4+-N 去除率稳定在 95%以上(图 2),同时出水
对不同微生物聚集体中的总菌、AOB 和 NOB 群落 -
NO2 -N 浓度出现明显增加,出水 NO2 -N 浓度和
-
350
60
NH4+-N 去除率
去除率(%)
120 18 0.20
NH4+-N 去除率 FA 浓度 12 AOB 活性
微生物活性(mgN/h VSS)
-
NO2 -N 积累率 FNA 浓度 16 NOB 活性
100 10
14 0.15
8
80 12
NH -N 去除率(%)
NO -N 积累率(%)
6
FA(mg/L)
FA(mg/L)
10
60 0.10
+4 - 2 8 4
40
6
0.05
2
阶段Ⅰ 阶段Ⅱ 阶段Ⅲ 阶段Ⅳ
20 4
图3 不同阶段中 AOB 和 NOB 的活性
2
Fig.3 Activity of AOB and NOB in different stages
0 0.00
阶段Ⅰ 阶段Ⅱ 阶段Ⅲ 阶段Ⅳ
运行阶段
进一步分析 NH4+-N 浓度对 AOB 活性的影响,
图2 不同阶段中 FA 和 FNA 对系统的影响
采用 Haldane 动力学模型分析底物物质 NH4+-N 对
Fig.2 The influence of FA and FNA on the system in different
AOB 增长速率的影响,王秀杰等[35]通过比较多种动
stages
力学模型,认为采用 Haldane 模型能够较好拟合不同
目前有研究报道羟胺(NH2OH)能够促进部分亚 初始 NH4+-N 浓度和 FA 浓度下对 NH4+-N 的降解
硝化的发生,同时能够完全抑制 NOB 的生长[32 33]. 过程.本实验对不同初始 NH4+-N 浓度条件下 AOB
-
1.6
1.4 Haldane 模型的 R2 为 0.9737,而孙洪伟等[37]所采用的
1.2 Aiba 模型的 R2 为 0.932.因此本实验中所拟合的结果
1.0
实验数据点 更具有准确性.
0.8
Haldane 模型拟合曲线 2.3 生物膜和悬浮污泥对氨氮去除分析
+4 0.6
0.4 有学者认为对于 NH4+-N 的降解,除了传统意义
0.2
的硝化反硝化除氨过程外,在此过程中 AOB 和 NOB
0
对 NH4+-N 的生物吸附也起到了重要作用 [38 39].
-
0 200 400 600 800 1000
NH4+-N(mg/L)
Schwitalla 等[40]发现如果忽略悬浮污泥对 NH4+-N
的吸附量时,则可能低估 10%~25%的 NH4+-N 被用
0.14
(b)
0.12
Y=0.26X/(27.64+X+(X2/74.94)) 于硝化过程的能力,悬浮污泥对 NH4+-N 的吸附能力
NO -N 生成速率(gN/dVSS)
2
R =0.9737
0.10 在 0.07~0.20mgNH4+-N/gVSS 之间,同时王昌稳等[41]
0.08 通过悬浮污泥对 NH4+-N 的吸附性能进行测定时发
0.06 现 悬 浮 污 泥 对 NH4+-N 的 最 大 吸 附 量 为
实验数据点
- 0.04 Haldane 模型拟合曲线 1.18mgNH4+-N/gVSS,Temmink 等[42]研究发现在生
物膜中同样具有对 NH4+-N 的吸附作用,吸附比例在
0.02
14%~27%之间.
0.00
0 100 200 300 400 本实验中,3 组批试实验的进水 NH4+-N 浓度分
FA 浓度(mg/L)
别为 221.3,210.8 和 218.7mg/L.实验结果如图 5 和图
+
图 4 (a)悬浮污泥中,NH4 -N 在前 5min 的去除量为 3.7mg/L, 6 所示.
+ +
此时悬浮污泥对 NH4 -N 的吸附值和图 4-(a)不同 NH4 -N 降 解 值 分 别 为 0.98mgN/gVSS 和 5.04mgN/
浓度下的抑制动力学模型;(b)不同 FA 浓度下的抑制动力
(h·VSS)(图 6),经过 1250min 后,NH4+-N 浓度降至
学模型 - -
Fig.4 (a)The kinetic of inhibition under different NH4+-N 6.8mg/L,NO2 -N、NO3 -N 出水浓度分别为 158.5,
concentrations;(b)The kinetic of inhibition under 40.3mg/L;如图 5(b)和图 6 所示,经过 1250min 后生物
different FA concentrations 膜对 NH4+-N 的吸附值和降解值分别为 1.21mgN/
gVSS 和 1.56mgN/(h·VSS),悬浮污泥对 NH4+-N 的吸
此外有研究表明,FA 在一定程度上能够促进氨 附值小于生物膜对 NH4+-N 的吸附值,而生物降解
氧化反应的进行,只有当 FA 到达一定阈值时,FA 对 值远远高于生物膜中对 NH4+-N 的生物降解值,实
AOB 的抑制作用才会显现 [36],因此本实验对不同 验结果表明在悬浮污泥中主要以生物降解为
+
主,Shao 等[22]研究发现在悬浮污泥中的 AOB 功能
-
FA 浓度下的 NH4 -N 通过 AOB 转化成 NO2 -N 的
生成速率作为衡量 AOB 活性的动力学参数,实验结 基因的总数比生物膜中的高,还有可能随着微生物
果 如 图 4(b) 所 示 , 本 实 验 结 果 表 明 当 FA 为 的代谢,生物膜内部发生脱落导致生物膜外层 AOB
的减少,进而导致生物膜上对于 NH4+-N 的降解值
-
50.47mg/L 时 ,NO2 -N 最 大 生 成 速 率 为 0.26gN/
(d·VSS),Ks 和 Ki 分别为 27.64 和 74.94mg/L,R2 为 比悬浮污泥低[43].相对于悬浮污泥和和生物膜的对
0.9737.孙洪伟等[37]通过 Aiba 模型对 AOB 的活性进 照实验(悬浮污泥+生物膜)经过 650min 后,NH4+-N
行动力学拟合,发现最大比亚硝酸盐氮产生速率为 的 吸 附 值 和 降 解 值 分 别 为 1.35mgN/gVSS 和
0.37g/(g·d),饱和常数(Ks)为 11.78mg/L;抑制常数(Ki) 7.47mgN/(h·VSS),最终出水 NH4+-N 浓度降低至
为 153.74mg/L,R2 为 0.932.在不同的 FA 浓度下,亚硝 - -
2.1mg/L,出水 NO2 -N、NO3 -N 浓度分别为 159.2,
1512 中 国 环 境 科 学 40 卷
160
120
80 AOB 的比例比生物膜中 AOB 的比例高 62.4%;在阶
40
0 -
0 200 400 600 800 1000 1200 段Ⅱ中,NO2 -N 出现积累现象,NOB 活性出现抑制,
240
200 b 生物膜 此 时 在 悬 浮 污 泥 中 AOB 约 占 总 菌 数 量 的
浓度(mg/L)
160
120
80 34.6%,NOB 约占总菌数量的 28.9%;生物膜中 AOB
40
0 约占总菌数量的 12.3%,NOB 约占总菌数量的 8.7%.
0 200 400 600 800 1000 1200
240
200 c 悬浮污泥+生物膜 由于生物膜生长较为缓慢,因此在生物膜中 AOB 的
浓度(mg/L)
160
120 相对含量比悬浮污泥中 AOB 的相对含量低;在阶段
80
Ⅲ中,随着 NH4+-N 进水浓度的升高,NO2 -N 得到大
-
40
0
0 200 400 600 800 1000 1200
量积累,实现了对 NOB 的抑制作用,此时在悬浮污泥
t(min)
中 AOB 约占总菌数量的 36.8%,NOB 约占总菌数量
图5 不同微生物聚集体中 NH4+-N,NO2--N 和 NO3--N 浓度
的 8.7%,生物膜中 AOB 约占总菌数量的 14.9%,NOB
变化
Fig.5 The change of NH4+-N,NO2--N and NO3--N 约占总菌数量的 9.7%;阶段Ⅳ中,悬浮污泥中 AOB
concentration in different microbial aggregates 约占总菌数量的 41.3%,NOB 约占总菌数量的 8.3%,
生物膜中 AOB 约占总菌数量的 18.1%,NOB 约占总
10 900
NH4+-N 吸附值 菌数量的 4.7%.
800
NH4+-N 降解值
8
NH -N 降解值(mgN/h VSS)
NH -N 吸附值(mgN/VSS)
生物量 700
600
生物量(mg)
6
500
4 400
+4
+4
300 阶段Ⅰ悬浮污 泥阶段Ⅰ生物膜
2
200
0 100
悬浮污泥 生物膜 悬浮污泥+生物膜
microbial aggregates
2.4 生物膜和悬浮污泥上微生物群落分析
采 用 荧 光 原 位 杂 交 技 术 (FISH) 分 别 对 Ⅰ 、
Ⅱ、Ⅲ、Ⅳ这 4 个阶段的不同微生物聚集体中硝化 阶段Ⅲ悬浮污泥 阶段Ⅲ生物膜
[1] Huihui C, Liang Z, Qiong Z, et al. Stable partial nitrification of activity of a partial nitritation SBR treating landfill leachate with
domestic sewage achieved through activatedsludge on exposure to extremely high nitrogen concentration [J]. Bioresource Technology,
[2] Kuai L P, Verstraete W. Ammonium removal by the oxygen-limited [16] Miao Y Y, Peng Y Z, Zhang L, et al. Partial nitrification-anammox
autotrophic nitrification-denitrification system [J]. Applied and (PNA) treating sewage with intermittent aeration mode: Effect of
Environmental Microbiology, 1998,64(11):4500-4506. influent C/N ratios [J]. Chemical Engineering Journal, 2018,334:664-
removal from reject water by partial nitrification and subsequent [17] Liu T, Mao Y J, Shi Y P, et al. Start-up and bacterial community
anammox [J]. Journal of Bioscience and Bioengineering, 2010,110(4): compositions of partial nitrification in moving bed biofilm reactor [J].
[4] Váquez-Padín J, Mosquera-Corral A, Campos J L, et al. Microbial [18] Onnis-Hayden A, Dair D, Johnson C, et al. Kinetcis and nitrifying
community distribution and activity dynamics of granular biomass in a populations in nitrogen removal processes at a full-scale integrated
CANON reactor [J]. Water Research, 2010,44(15):4359-4370. fixed-film activated sludge (IFAS) plant [J]. Proceedings of the Water
[5] Lan C J, Kumar M, Wang C C, et al. Development of simultaneous Environment Federation, 2007,(15):3099-3119.
partial nitrification anammox and denitrification (SNAD) process in a [19] Kim H S, Schuler A J, Gunsch C K, et al. Comparison of conventional
sequential batch reactor [J]. Bioresource Technology, 2011,102(9): and integrated fixed-film activated sludge systems: Attached- and
5514-5519. suspended-growth functions and quantitative polymerase chain
[6] Peng Y Z, Zhu G B. Biological nitrogen removal with nitrification and reaction measurements [J]. Water Environment Research, 2011,83(7):
denitrification via nitrite pathway [J]. Applied Microbiology & 627-635.
Biotechnology, 2006,73(1):15-26. [20] Yang S H, Peng Y Z, Zhang L, et al. Autotrophic nitrogen removal in
[7] Strous M, Kuenen, Jetten S M S. Key pyhsiology of anaerobic an integrated fixed-biofilm activated sludge (IFAS) reactor: Anammox
ammornia [J]. Applied and Environmental Microbiology, 1999,65(7): bacteria enriched in the flocs have been overlooked [J]. Bioresource
3248-3250. Technology, 2019,288:121512.
[8] 程 军,张 亮,张树军,等.氨氮负荷波动对城市污水短程硝化-厌 [21] 国家环境保护总局水与废水监测分析方法编委会.水和废水监测分
氧氨氧化工艺硝态氮的影响 [J]. 中国环境科学, 2017,37(2):520- 析方法 [M]. 4 版.北京:中国环境科学出版社, 2002.
525. State Environmental Protection Administration. Determination
1514 中 国 环 境 科 学 40 卷
methods for examination of water and wastewater (4th Ed) [M]. & Technology, 2015,73(5):1067-1073.
Beijing: China Environmental Science Press, 2002. [34] Joo H S, Hirai M, Shoda M. Characteristics of ammonium removal by
[22] Shao Y, Yang S, Mohammed A, et al. Impacts of ammonium loading heterotrophic nitrification-aerobic denitrification by Alcaligenes
on nitritation stability and microbial community dynamics in the faecalis No.4 [J]. Journal of Bioscience and Bioengineering, 2005,
integrated fixed-film activated sludge sequencing batch reactor 100(2):184-191.
(IFAS-SBR) [J]. International Biodeterioration & Biodegradation, [35] 王秀杰,王维奇,李 军,等.氨氮对异养硝化菌 Acinetobactor sp.活性
2018,133:63-69. 影响及动力学特性分析 [J]. 中国环境科学, 2018,38(3):943-949.
[23] Yang Y, Zhang L, Cheng J, et al. Achieve efficient nitrogen removal Wang X J, Wang W Q, Ji J, et al. Inhibition of initial ammonia and free
from real sewage in a plug-flow integrated fixed-film activated sludge ammonia nitrogen on Acinetobactor sp.and their biokinetics [J]. China
(IFAS) reactor via partial nitritation/anammox pathway [J]. Environmental Science, 2018,38(3):943-949.
Bioresource Technology, 2017,239:294-301. [36] Ge S, Wang S, Yang X, et al. Detection of nitrifiers and evaluation of
[24] Anthonisen A C, Loehr R C, Prakasam T, et al. Inhibition of partial nitrification for wastewater treatment:A review [J].
nitrification by ammonia and nitrous-acid [J]. Journal Water Pollution Chemosphere, 2015,140(9):85-98.
Control Fedration, 1976,48(5):835-852. [37] 孙洪伟,于 雪,高宇学,等.游离氨(FA)对氨氧化菌(AOB)活性抑制
[25] Anthonisen A C, Loehr R C, Prakasam T B, et al. Inhibition of 动力学试验 [J]. 环境科学, 2018,39(9):4294-4301.
nitrification by ammonia and nitrous acid [J]. Journal - Water Pollution Sun H W, Yu X, Gao Y X, et al. Inhibitory kinetics of free ammonia
Control Federation, 1976,48(5):835. (FA) on ammonia-oxidizing bacteria (AOB) [J]. Environmental
[26] 赵 青,卞 伟,李 军,等. DO/NH4+-N 调控实现 MBBR 工艺生活 Science, 2018,39(9):4294-4301.
污水短程硝化 [J]. 中国环境科学, 2017,37(12):4511-4517. [38] Guibaud G, Tixier N, Bouju A, et al. Relation between extracellular
Zhao Q, Bian W, Li J, et al. DO/NH4+-N control to achieve partial polymers composition and its ability to complex Cd, Cu and Pb [J].
nitrification of municipal wastewater in MBBR process [J]. China Chemosphere, 2003,52(10):1701-1710.
Environmental Science, 2017,37(12):4511–4517. [39] Zhang D, Pan X, Mostofa K M G, et al. Complexation between Hg(II)
[27] Gang W, Xu X, Zheng G, et al. Study of simultaneous partial and biofilm extracellular polymeric substances: An application of
nitrification, ANAMMOX and denitrification (SNAD) process in an fluorescence spectroscopy [J]. Journal of Hazardous Materials, 2010,
intermittent aeration membrane bioreactor [J]. Process Biochemistry, 175(1-3):359-365.
2016,51(5):632-641. [40] Schwitalla P, Mennerich A, Austermann-Haun U, et al.
[28] Anthonisen A C, Loehr R C, Prakasam T, et al. Inhibition of NH(4)(+)-/desorption in sequencing batch reactors: simulation,
nitrification by ammonia and nitrous-acid [J]. Journal Water Pollution laboratory and full-scale studies [J]. Water Science & Technology A
Control Fedration, 1976,48(5):835-852. Journal of the International Association on Water Pollution Research,
[29] Fux C, Lange K, Faessler A, et al. Nitrogen removal from digester 2008,58(2):345.
supernatant via nitrite - SBR or SHARON [J]. Water Science and [41] 王昌稳,赵白航,李 军,等.好氧颗粒污泥吸附氨氮性能 [J]. 化工学
Technology, 2003,48(8):9-18. 报, 2014,65(3):942-947.
[30] Wang B, Peng Y, Guo Y, et al. Impact of partial nitritation degree and Wang C W, Zhao B H, Li J, et al. Performance of ammonia adsorption
C/N ratio on simultaneous sludge fermentation, denitrification and by aerobic granular sludge [J]. CIESC Journal, 2014,65(3):942-947.
anammox process [J]. Bioresource Technology, 2016,219:411-419. [42] Temmink H, Klapwijk A, De Korte K F. Feasibility of the
[31] Anthonisen A C, Loehr R C, Srinath T B S P G. Inhibition of BIOFIX-process for the treatment of municipal wastewater [J]. Water
nitrification by ammonia and nitrous acid [J]. Journal (Water Pollution Science & Technology, 2001,43(1):241-249.
Control Federation), 1976,48(5):835-852. [43] Shao Y, Shi Y, Mohammed A, et al. Wastewater ammonia removal
[32] Kindaichi T, Okabe S, Satoh H, et al. Effects of hydroxylamine on using an integrated fixed-film activated sludge-sequencing batch
microbial community structure and function of autotrophic nitrifying biofilm reactor (IFAS-SBR): Comparison of suspended flocs and
biofilms determined by in situ hybridization and the use of attached biofilm [J]. International Biodeterioration & Biodegradation,
microelectrodes [J]. Water Science & Technology A Journal of the 2017,116:38-47.
International Association on Water Pollution Research, 2004,49(11/
12):61. 作者简介:张 凯(1990-),男,河北邢台人,北京工业大学博士研究生,
[33] Wan X Y, Xiao P Y, Zhang D J, et al. The kinetics for ammonium and 主要从事污水处理及资源化研究.发表论文 3 篇.
nitrite oxidation under the effect of hydroxylamine [J]. Water Science