Professional Documents
Culture Documents
Plate No. 3 - Timber Design
Plate No. 3 - Timber Design
3 – TIMBER DESIGN
INSTRUCTIONS. SOLVE EACH SITUATIONAL PROBLEM WITH FULL SINCERITY AND HONESTY. ERASURES ARE NOT ALLOWED ON YOUR
FINAL ANSWERS. FINALIZE ALL YOUR ANSWERS USING PERMANENT PEN.PLACE YOUR FINAL ANSWERS ON A SEPARATE PAGE OF
PAPER. NO SOLUTIONS, NO POINTS.
A wooden beam 2Y0mm x 4Z0mm has a single span of 6m. If the beam weight is 6.3 KN/m 3 and its allowable bending and shearing stresses are
12.X and 0.8Y MPa respectively.
A single span member is 3.Z m in length and is made up of wood 2Y0mm x 4Z0mm wooden section. Use your reference type of wood using NSCP
2015. The beam carries a uniform load of 18.Z KN/m besides its own weight. Weight of wood is given by 8.XY KN/m3. The beam carries on axial
tensile load of 17Y.Z KN.
1. What is the actual tension/tensile stress in the beam if only tensile force was acting?
2. What is the interaction value of both bending and tensile stress?
3. Determine the ratio of the difference between the actual bending and tensile stress to the adjustment bending stress of slenderness.
SAMPLE GIVEN:
2XY.Z mm -> 245.6 mm
5.XZ KN -> 5.46 KN