Professional Documents
Culture Documents
EXERCISES NO. 1
Object 1: Enumerate the different steps use the same format as presented in the module.
Work Out all the different objects in exercises 1.
A. REFRIGERATOR
Figure 1 Figure 2
B. CENTER TABLE
Figure 1
Figure 2
C. SIDE TABLE
First Circle
Command: CIRCLE: Click the circle icon in the Draw Panel
Click in drawing space then drag hold
Command line window: Specify radius or diameter: type d for diameter / enter (use d)
Specify the value of d: type 60/enter (Figure A)
Second Circle
Command: CIRCLE: Click the circle icon in the Draw Panel
Click in drawing space then drag hold
Command line window: Specify radius or diameter: type d for diameter / enter (use d)
Specify the value of d: type 250/enter (Figure B)
Third Circle
Command: CIRCLE: Click the circle icon in the Draw Panel
Click in drawing space then drag hold
Command line window: Specify radius or diameter: type d for diameter / enter (use d)
Specify the value of d: type 400/enter (Figure C)
D. GAS RANGE
Command: RECTANGLE: Click the Rectangle Icon in the Draw Panel
In the Drawing Space: Start Point: Click in the Drawing space/drag/hold
Format: type @700,650/enter (x,y values) (Figure A)
REPEAT all the commands on all sides of the Circle. Shown in (Figure E)
Command: LINE: Click the line icon in the Draw panel tool
In the drawing space: Click the corner point in the Line 2
Command line: Specify next point: type 89
Specify next point: type 17
Specify next point: type 64
Specify next point: type 17
Specify next point: type 59
Specify next point: type 17
Specify next point: type 64
Specify next point: type 17
Specify next point: type 59
Specify next point: type 17
Specify next point: type 64
Specify next point: type 17
Specify next point: type 59
Specify next point: type 17
Specify next point: type 64
Specify next point: type 17
Specify next point: type 59
Specify next point: type 17
Specify next point: type 64
Specify next point: type 17
Shown in (Figure F)
Figure E
E. LAVATORY 1
Command: RECTANGLE: Click the Rectangle Icon in the Draw Panel
In the Drawing Space: Start Point: Click in the Drawing space/drag/hold
Format: type @400,400/enter (x,y values) (Figure A)
Command: EXPLODE
In the command line: Select objects
In drawing space: Select all the objects
In command line: Specify opposite corner
In drawing space: drag and hold / enter
Shown in Figure E
F. LAVATORY 2
Command: EXPLODE
In the command line: Select objects
In drawing space: Select all the objects
In command line: Specify opposite corner
In drawing space: drag and hold / enter
G. STOVE
FILLET
Command: Click FILLET icon from modify panel
Command Line: Select first object or (Undo Radius Trim Multiple): Type R/enter
Specify Fillet Radius: Type 50/enter
In the Drawing Space: Click line 1 & line 4 / enter = A
Click line 1 & line 2/ enter = B
Click line 2 & line 3/enter = C
Click line 3 & line 4/ enter = D (Figure B)
In the Drawing Space: click the guide lines inside the rectangle; click delete on keyboard
H. STOVE BURNER
I. BATH TUB
Command: EXPLODE
In the command line: Select objects
In drawing space: Click the objects to be exploded
In command line: Specify opposite corner
In the drawing space: drag / hold / enter (Figure 2)
Command: OFFSET: Click offset icon from the modify panel
Command Line: Specify distance to offset: Type 100/ enter
In drawing space: click the Line 1 object to the right/ enter
J. SINGLE BED
K. MATRIMONIAL BED