Professional Documents
Culture Documents
◆ Trouble Shooting……………………………………………………………..……......31
Y/PB/P
R In
HDMI1
AV In 1
Y/PB/PR
And VGA AV In 2 AV Out VGA In Tuner Speaker
Audio In socket
MS82D/E Interface Introduction
Power KEY IR LVDS Speaker
Suppy Board Board Cable socket
Board
Power
Supply
Socket
AV1 IN
HDMI1 VGA
USB2
Y Pb Pr
Power AUDIO IN
Supply Share with
Speaker Socket USB1
socket VGA AV2
LVDS
Cable
AV1 IN
IR IN Tuner
HDMIN
2 IN
KEY IN
AV OUT Y PB Pr IN Av2 VGA In HDMI1
share with Y IN
MS82B/C/D/E /F Main Difference
U 803
3.3V TO DDR 1.8V
MAIN IC
U 806
12V TO DDR 1..26V
12V to 5V
Amplifier
MS82D/E Key Components Introduction
24V DC DC 3.3V TO
TO 12V 1.8V DDR
Flash
HDMI U600
SWITCH Amplifier
Main IC
3.3V TO
2.5V
24V DC DC
TO 12V 12V to
3.3V Flash
3V3 to
DDR2 1V8
U601
Amplifier
Main IC
HDMI
SWITCH
12V to 5V 12V to DC
1.26V
MS82B/C/D/E/L Key Components List
Part No. Component Type / Model location
13-AP2111-25B 3.3v to 12.5V Supply IC CMOS LDO 2.5V U801
U808(ms82D/
13-DC1582-ENB33 24V to 12V IC DC/DC TSOT MP1582
ms82L)
IC DC/DC TSOT
13-MP1494-DJB 12V to 5V Supply U805
MP1494DJ
IC DC/DC TSOT
13-MP1494-DJB 12V to 3.3V Supply U807
MP1494DJ
IC DC/DC TSOT
13-MP1494-DJB 12V to 1.26VV Supply U806
MP1494DJ
3V3 to 1.8V DDR
13-AS1117-18B AS1117-18 CX U803
POWER Supply
IC 32M FLASH SOIC
13-W25Q32-FVB Flash U102
W25Q32FV
U101
IC MAIN IC TTX
13-MST3E1-* MS82B/E/F
13-MST3M1-* U101
MAIN IC
IC
MS82C/D/L
Signal Flow Diagram
1.Signal Flow SOUND POWER
MS82D/E :MSH9010
MS82B/C/L/F :ST380BW
Signal Flow Diagram
MS82B/C/D /E.Power Supply Flow
MS82L/MS82F POWER
Only this module is
different from MS82D
Signal Flow Diagram
3. I²C Bus Block Diagram
MST3M182VG/MST3E182
VG
HDMI
TUNER
SWITCH
IC
MS82D/E uses Analog Audio Amplifier - MSH9010 which uses it’s own
control protocol.
Key Test Point
1.The Key Test Point Of Power Supply
Key Test Point
2.The Key Test Point Of 24V To 12V
When TV set working normally, the voltage of each pin of U806 is like
below:
Pin 1: 0.2V Pin 8:6.2V
Pin 2: 12V Pin 7:4.8V
Pin 3: 1.6V Pin 6:5.1V
Pin 4: GND Pin 5:6.2V
Key Test Point
4.The Key Test Point Of 12V To 5V
R135 R136
HD Panel NC NEED
Full HD panel NEED NC
Remarks:
R133 & R134 are not used in
MS82 MainBd.
Panel work model
Panel work model control by LVDS SEL. Panel have two work
model JEDEC or NORMAL
Unit Circuit Analysis and Testing
2.Backlight DIMMING CONTROL
(1) If our backlight is led, the D807 and C891 are not need. R858 use 0 OHM
resistance.
This ic is IIS
Don’t start
Check power No Is Power board 3.3V
board STB, 12V/24V normal?
Only3.3V Yes
Yes
Abnormal Picture
Check peripheral
components of u101
Trouble Shooting
Y
Check the waveform of P601. Check
Check the input Y OK? Speakers.
coupling
circuit .OK? N
Y Check the
N Check the MUTE OK? wave of Q603
and Q604
Check the relevant
N
signal source
circuit. Y
Check the status Check the MUTE circuit N
of U101
Replace
U601.
Replace
U101 Check q603
and Q604
Software update
1, First, we should copy the sotware to my USB disk root directory.