You are on page 1of 2

TROUBLE SHOOTING INTERFACE

MONO-MOTRONIC 45 SIGNAL LOCATIONS

Interface – Signal Locations


1. Ground
2. Control signal to idle speed correction valve
3. Control signal to tank ventilation valve
4. Ground to diagnostic link*
1
5. Not connected 24
6. Not connected 2
7. Control signal to injection valve 25
3
8. Power feed to Hall sensor 26
9. Engine speed signal to revolution counter 4
27
10. Signal from idle switch 5
11. Diagnosis* 28
6
12. Ground* 29
13. Engine speed signal from Hall sensor 7
14. Power feed to throttle potentiometer 30
8
15. Ground to lambda sensor 31
16. Signal from idling regulator 9
32
17. Ground to sensor 10
18. Signal from throttle potentiometer #2 33
19. Signal from knock sensor *
11
34
20. Ground 12
21. Constant power feed from battery 35
13
22. Not connected 36
23. Power feed from ignition switch 14
37
24. Engine speed signal (Tn) to ignition amplifier 15
25. Control signal to fuel pump relay 38
26. Control signal to idle speed correction valve 16
39
27. Status signal fuel consumption 17
28. Control signal to inlet air pre-heating* 40
18
29. Diagnosis 41
30. Not connected 19
31. Not connected 42
20
32. Not connected 43
33. AC* 21
44
34. Status signal from automatic gear box* 22
35. AC* 45
36. Speed signal 23
37. Not connected
38. Signal from lambda sensor
39. Ground to knock sensor
40. Power feed from ignition switch, if automatic*
41. Signal from throttle potentiometer #1
42. Signal from coolant temperature sensor
43. Signal from air temperature sensor
44. Shield for lambda sensor *
45. Shield for knock sensor *
Note: Connector viewed from below
* Only certain systems
54 A01090226-1
TROUBLE SHOOTING
WIRING DIAGRAM MONO-MOTRONIC 45

Wiring Diagram
This wiring diagram is an example. Check in the relevant workshop
manual for the diagram of the car you are working with.

Control unit Battery


Mono-Motronic 45
Knock sensor Tank ventilation

Throttle potentiometer
Ignition switch

10 A
Coolant temperature sensor 20 A Fuel pump
relay
Fuel pump
Air temperature sensor
Relay
Hall sensor

Computer
Suction pipe heating
Air conditioner

Automatic gear box


Injection valve
Revolutions
Speed

Diagnosis Ignition Ignition coil


amplifier

Lambda sensor
Idle switch

Lambda sensor pre-heating Idle speed


regulator

A01090226-1 55

You might also like