Professional Documents
Culture Documents
Equations
Progression
Profit & Loss
Ratio and Proportion
Mensuration
Logarithms
Simple and Compound Interest
Trigonomtery
Mixture and Allegations
Divisibility
Series and Progression
HCF and LCM
Areas
Numbers,Relations and Functions
Pipes and Cisterns
Time and Work
Probability/Pnc
Permutation and Combination
Percentage
Speed and Distance
Averages
Geometry
Sentence Correction
Prepositions
Grammar
Reading Comprehension
Synonyms & Antonym
Idioms and Phrases
Speech and Tenses
Article
Sentence Selection
Spotting Error
Sentence Completion
Arrangements
Visual Reasoning
Blood Relations
Flowcharts-Visual Reasoning-DI
Statement & Conclusions
Coding Decoding
Agree Degree pshychometric
Directional Sense
Analogies
Seating Arrangement
Inferred Meaning
Logical Sequence
Only (i)
(i) and (ii)
(ii) and (iii)
Only (iii)
ans:Only(iii)
Q2.Which of the following types of wood is used in manufacturing of the sports
goods?
Mulberry
Mahogany
Sal
Deodar
ans: Mulberry
white patches
black patches
red patches
orange patches
ans:white patches
Q4.____________ is the method used to analyze and identify the minimum time
needed to complete the total project.
PERT
Gantt chart
GERT
None of the mentioned options
ans:PERT
Q5.In a construction site, an old dozer is replaced by a new one. If the useful life of
the new dozer is 2 years at an interest rate of 5%, then what is the sinking fund
factor?
0.48
0.78
0.08
0.28
ans: 0.48
Q6.What is the percentage increase in the strength of the concrete from 3 weeks of
construction to the 1 year of construction?
10% to 15%
20% to 25%
30% to 35%
40% to 45%
Ans:20% to 25%
Q7.In concrete, the use of aggregate with low poisson’s ratio increases the:
impact strength
life of concrete
shrinkage
both impact strength and shrinkage
Only (i)
(i) and (ii)
(ii) and (iii)
(i), (ii) and (iii)
Ans: Only(i)
i)
ii)
iii)
iv)
Only (i)
Only(ii)
(iii)and(iv)
(i)and(ii)
Ans: Only(ii)
roof
wall
floor
furniture
Ans: Furniture
Q13.For a material following Hooke’s law, if the elastic modulus and shear modulus
are 5 x 105 MPa and 3 x 105 Mpa respectively, then determine the bulk modulus of
the material.
1.25 x 105 MPa
2.25 x 105 MPa
3.25 x 105 MPa
4.25 x 105 MPa
1.2 cm2
1.8 cm2
2.2 cm2
2.8 cm2
0.003125 cm
0.005125 cm
0.007125 cm
0.009125 cm
Ans:0.003125 cm
water
nitrogen
carbon
sulphur
Ans: water
Q18.Which of the following is/are the by-products obtained from the thermal power
plants?
i) Fly ash
ii) Gypsum
iii) Slag
Choose the correct answer from the options given below.
Only (i)
(i) and (ii)
(ii) and (iii)
(i), (ii) and (iii)
Only (i)
(i) and (ii)
(ii) and (iii)
(i), (ii) and (iii)
Q20. If the total and effective stresses at certain depth of the swimming pool are 0.5
kg/cm2 and zero respectively, then what is the depth corresponding to the stresses?
0m
5m
10 m
15 m
Ans: 5 m
Q21.In a triaxial test of dry sand specimen, the cell pressure is 30 kPa and the
deviator stress at failure is 60 kPa. Determine the angle of internal friction of the
sand specimen.
30o
10o
45o
60o
ans: 30o
Q22.A 50 cm diameter friction pile is embedded into a 10 m homogeneous
consolidated deposit. The unit adhesion developed between clay and pile shaft is 5
t/m2 and adhesion factor is 0.5. What is the safe load for a factor of safety 2.5?
(Note: “t” = ton)
15.70 t
16.70 t
17.70 t
18.70 t
Ans: 15.70 t
Structure
Free body diagram
Machine
Concrete
Ans: Structure
Columns
Arches
Catenaries
All of the mentioned options
Q25.Two forces “P” and “Q” are acting at a point of “O” as shown in the figure. Determine the
magnitude of the resultant force.
Ans: 94.5 N
Q26.Which of the following is the most appropriate place for fixing the rainguage, to get the most
accurate results?
Q27.The sodium absorption ratio (SAR) of an irrigation water from the bore well is
14, if the concentration of the calcium ( Ca++ ) and magnesium ( Mg++ ) are 10 and 8
respectively, what is the concentration of the sodium ( Na ++ ) in the water?
12
22
32
42
Ans: 42
Q28.A dam is constructed on a river with a total storage capacity of 40 million cubic
metres and dead storage of 10 million cubic metres. If the average volume of
sediment deposition is 0.20 million cubic metre per year, how many years will it take
to reduce the usefulness of the dam?
50 years
30 years
15 years
55years
Ans: 50 years
Q29.At a 50 m stage, a river is carrying a discharge of Q m 3/sec with a water surface
slope of (1/1000). Determine the water surface slope of a river at the same point and
same stage of 50 m with river carrying half the discharge.
1/2000
1/3000
1/4000
1/5000
Ans: 1/4000
Q30.From the following four hydrological features, what is the first step employed in
computing the flood hydrograph at any catchment outlet?
1. unit hydrograph
2. rainfall hydrograph
3. infiltration index
4. base flow
Choose the correct answer from the options given below.
1
2
3
4
Ans: 2
Concepts of Mathematics including Time & Work, Speed & Distance, Algebra, Equations,
Progressions, Profit & Loss, Ratios, Averages, Geometry and Data Interpretation
Building Materials, RCC Design, Theory of Design & Structures, Soil Mechanics & Foundation,
Construction Scheduling, Water Resource Engineering / Hydrology, Geotechnical Engineering
and Environmental Engineering