Professional Documents
Culture Documents
TM
6 000 psig
P6E Choke
6 000 psig / Max Cv 400 / Max Bean Size 304
This choke valve uses a bolted bonnet to retain the flow
trim in the valve body. The flow trim is pressure balanced to
minimize the stem loads and provide low operating torques.
Standard end connections range in size from 6” to 8”.
B
above. Special dimensions and other end connections are
available upon request.
Dimensions I
inch mm
A 33.50 851 INLET
B 28.00 711
C 48.00 1219
O A
Note: “C” is the disassembly clearance. C
6A-0138 17D-0008
P6E Choke 6 000 psig / Max Cv 400 / Max Bean Size 304
PERFORMANCE
CHARACTERISTICS P6 Cv Curve - Enhanced Trim
450
400
350
300
Cv 250
200
150
100
50
0
0% 10% 20% 30% 40% 50% 60% 70% 80% 90% 100%
Stem Travel
LIQUID PRESSURE Master Flo’s trim geometry has been designed to achieve high FL numbers. This results in a
RECOVERY FACTOR decreased cavitation potential, lower noise generation, increased flow capacity, and longer trim
life.
(F L) The high FL numbers of Master Flo’s trims have been verified experimentally as per the test
procedures of ISA-S75.02-1996.
6 000 psig / Max Cv 400 / Max Bean Size 304 P6E Choke
24
PARTS LIST
1. Body
2. Seal: Seat - Body
25 3. B/U Ring: Cage - Seat
26 4. Seal: Cage - Seat
5. Seat
27 6. Cage
7. External Sleeve
8. Retaining Sleeve
23 9. Seal: External Sl. - Balance Sl.
28
22 10. B/U Ring: External Sl. - Balance Sl.
29 11. External-Sleeve Bushing
21
30 12. Lockwasher
20 13. Balance Sleeve
29
19 14. Spring Pin
31 15. Retaining Ring
18 16. Seal Pack: Stem - Bonnet
32
17 17. Spacer
18. Key: Stem - Bonnet
16
19. Bonnet
15 20. Cover Plate
14 21. Grease Nipple
33
22. Stem Nut
13
23. Key
12 34 24. Calibration Head
35 25. Handwheel
26. Capscrew
36
27. Capscrew
37 28. Wiper
29. Thrust Washer
30. Thrust Bearing
31. Stem
11 32. Capscrew
10 33. Seal: Balance Sleeve - Bonnet
34. Spring Pin
9
35. B/U Ring: Balance Sleeve - Body
36. Seal: Balance Sleeve - Body
37. Pin
8
7
6
5
4
3
2
1
w w w. m a s t e r f l o . c o m
info@masterflo.com
info@masterflo.co.uk