Professional Documents
Culture Documents
pinoybix.org/2015/04/reviewer-in-chapter-3-amplitude-modulation-circuits.html
2. Amplitude modulation can be carried out by linearly combining the carrier and
intelligence signals then applying the result to a nonlinear component or
circuit. A diode is an example.
3. The simplest AM circuit uses resistors to linearly mix the carrier and
information signal, a diode to rectify the result, and a tuned circuit to complete the
waveform.
8. For 100 percent high-level modulation, the modulation amplifier must produce an out
put wave whose peak-to-peak is 2 times the collector supply voltage.
1/4
9. For 100 percent high-level modulation, the modulation amplifier must generate an
output power that is one-half of the final RF power amplifier input power (Pi =Vcc x Ic).
10. The simplest and best amplitude demodulator is the diode detector. The AM signal is
rectified by a diode and then filtered by a capacitor to recover the envelope which is the
original modulating information.
11. Balanced modulators are AM circuits that cancel or suppress the carrier but
generate a DSB output signal that contains the upper (sum) and lower (difference)
sideband frequencies.
12. A popular balanced modulator is the lattice modulator that uses a diode bridge
circuit as a switch. The carrier turns the diodes off and on letting segments of the
modulating signal through to produce a DSB output signal. A carrier suppression of 40 dB
is possible.
13. Another widely used balanced, modulator is an integrated circuit (IC) using
differential amplifiers as switches to switch the modulating signal at the carrier
frequency. A popular device is the 1496 or 1596. Carrier suppression can be as high
as 50 to 65 dB.
14. The most common way of generating an SSE signal is to use the filter method which
incorporates a balanced modulator followed by a highly selective filter that passes either
the upper or lower sideband.
15. To make both sidebands available, SSB generators use two filters, one for each
sideband, or switch the carrier frequency to put the desired sideband into the fixed filter,
bandpass.
18. Crystals have series and parallel resonant modes. These can be combined into a lattice
(bridge) circuit that provides extremely sharp selectivity over a desired bandwidth.
19. Ceramic filters use ceramic resonators that act like crystals but are smaller and lower
in cost.
20. Mechanical bandpass filters are also used in SSE generators. These devices use
multiple resonant disks that vibrate at some frequency in the 200- to 500-kHz range.
2/4
21. The phasing method of SSE generation uses two balanced modulators and 90°
phase shifters for the carrier and modulating signal to produce two DSB signals that when
added cause one sideband to be canceled out.
22. In phasing-type SSE generators, the accuracy of the phase shifters determines the
degrees of unwanted sideband suppression.
23.Precision RC networks are normally used to produce the desired 90° phase shifts.
24. A demodulator for SSE is a mixer such as a balanced modulator that, is called a
product detector. The carrier is reinserted in the receiver with a local oscillator.
29. One of the most commonly used mixers is a single diode. Germanium or hot-carrier
diodes are used for mixing at very high radio frequencies.
30.The inputs to a mixer are the signal to be translated fs and a sine “wave fo from a local
oscillator (LO). The outputs are fo, fs, fo + fs, and fo – fs. A tuned circuit at the output
selects either the slim or difference frequency while suppressing the others. Any
modulation on the input appears on the output signal.
31. Bipolar and field-effect transistors can be used as mixers by operating them in
the nonlinear region of their characteristics.
32. Transistor mixers offer the benefit of gain over diode mixers.
34. Doubly balanced modulators and GaAs FETs are the best mixers at VHF, UHF,
and microwave frequencies.
35. A single transistor can be connected to perform both the mixer and LO functions. Such
a mixer is called a converter and is used primarily in AM receivers at frequencies below
30 MHz.
3/4
Pinoybix Engineering Copyright © 2020. | Ad Majorem Dei Gloriam!
4/4