You are on page 1of 3

This picture illustrates the process that ethanol fuel is produced from corn.

Additionally, it is a
linear process.

It is evident that there are 9 stages in the process of producing ethanol fuel, begin beginning
with harvesting corns and ending with delivering to gas stations selling the product in gas
station.

The process commences when a number of corns are cut down. Afterwards, those corns are
delivered and stored in a big barn or warehouses. In the following stage, after being milled into
powder corn to get the same pieces, these this flour is are cooked within 4 hours with an
unspecified amount of water added to. At the fifth stage, the cooked corn powder is fermented
in a fermenting tank for about 2 days in order to change the sugar in that corn the corns into
alcohol.
Following this, the fermented substance is separated into solid by-products and only liquid
remains. Whilst the solid-products are is eliminated, the liquidised substance is further purified
get fine ethanol under the laboratory conditions for another 5 hours. liquid is transported to a
lab, where ethanol is purified in 5 hours. Having been stored in a container, the product is
delivered to the gas stations for selling.

This picture illustrates how the waterfront area in Darwin changed over a the course of 5 years
from 2009.

It is evident that there were a number of shifts taking place in the area, such as: an increasing
the number of residential buildings, and the complete disapprearance or elimination of the
industrial site to make room for more residental and recreational amenities, and the town’s
infrastructure was also renovated with the addition of a harbour and more footpaths

In 2009, the footpath covered the lake and one industrial area. The other industrial zone was in
the west of the town. Outside the trail, in the north, there was a convention centre, and in the
northwestern corner, a school was built. Under the foothpath, there were 3 blocks of flats for
inhabitants. Additionally, there were two swimming pools in the waterfront area, one was
opposite to the lake, the other was next to the residential building. In addition, the fishing area
was constructed in the northeastern corner of the Darwin town.

In 2014, further transformations could be seen in the waterfront area. The former industrial
zones zone was were torn down to make room for a swimming pool, and residential block. The
foothpath was broadened with the addition of greenery and an academic institution, which was
is built in the west western town. Besides, the harbour was erected in the sea, whilst the fishing
area, and the complex area surrounded by the footpath remained unchanged.

You might also like