Professional Documents
Culture Documents
FIRMWARE UPDATE PROCEDURE 1. Add upgrade file ‘handheld.sig’ to a USB flash drive.
1. Add upgrade file ‘loadbank.sig’ to a USB flash drive.
Making sure the firmware is up to date on Ensure no other files with ‘.sig’ extension exist on the Ensure no other files with ‘.sig’ extension exist on the
SIGMALT load banks is important to maximise USB flash drive. USB flash drive.
load testing capabilities and to ensure
TOP TIP
correct operation. To obtain the upgrade files If ‘loadbank.sig’ and ‘handheld.
please visit www.ascopower.com/firmware sig’ update files are on the same
USB flash drive ‘loadbank.sig’
will take priority.
2. Connect the Hand-held to the Load Bank, insert the 2. Connect the Hand-held to the Load Bank, insert the
USB drive into the Hand-held and power up the load bank. USB drive into the Hand-held and power up the load bank.
TOP TIP
Connect the load banks in a
network to update multiple load
banks at the same time.
METERING METERING
V/Hz/kW V/Hz/kW
! ! METERING
Vx3 MODE Vx3 MODE V/Hz/kW
!
Ax3 Ax3 Vx3 MODE
ASCO Label P/N 1073470-001 Rev. C ASCO Label P/N 1073470-001 Rev. C
WARNING!
READ THE LOAD BANK MANUAL BEFORE USE
AND TAKE SPECIAL NOTE OF ALL SAFETY
WARNINGS.