Professional Documents
Culture Documents
DICOM®RF4050
The RF4050 is intended for installation in all tracked and wheeled
vehicles and base stations. The core component of the RF4050 is Modulation type FM, AM, CPM
the RF40 handheld radio. To maintain communications in dismount Transmission power max. 50 W
operations, the system’s “jerk-and-run” capability allows the hand-
GNSS
Built-in GNSS receiver for GPS, Glonass and
Galileo systems with automatic despatch of
positional reports (PLI) on the background of
voice or data communication - G-Track system.
Co-site performance
The transceiver is manufactured with or
without a co-site filter. Integrated co-site filters
make it possible to operate multiple radios
simultaneously at close distance.
Intercom
The RF4050 provides interface for connection
to vehicle intercom systems (e.g. VICM200
Combat).
Czech Republic
Subject to change without notice.
DICOM®RF4050
The RF4050 radio is equipped with two internal slots for Co-site filters EXT
(optional). These are necessary in situations with multiple radios in I
Interface to Data Terminal
one place (typically on a vehicle), which must simultaneously operate Equipment (BMS)
E
without interference. The decisive factor is then the distance between
VHF/UHF vehicular radio their antenna systems (their interconnection). — Ethernet 10/100
Co-site 30-88 MHz allows antennas to be placed at a minimum — USB 2.0 OTG
distance of about 1.5 m from each other (e.g. 2.6 m rod, monopole) — RS232C
with a minimum spacing of operating frequencies of 10 %. Other
Mode selector GNSS frequency variants of filters and customization according to specific
installation conditions on request.
Controlling of the vehicular radio is very simple and Interface to the passive or
intuitive. It is performed through the controls of the active GNSS antenna
RF40 handheld radio and does not differ from the
control of the handheld radio itself. AF VHF/UHF
Basic control is provided by the Mode Selector, which Interface for audio auxiliaries
activates the radio and selects basic operating modes. Two antenna interfaces
— microphone input
— on/off — 30 MHz to 512 MHz to VHF only
— speaker output
— channel selection or
— PTT input
— setup and programming — switching between VHF and UHF
— control and filling
— channel erase output (frequency selectable)
DICOM®RF4050
The RF4050 is intended for installation in all tracked and wheeled
vehicles and base stations. The core component of the RF4050 is Modulation type FM, AM, CPM
the RF40 handheld radio. To maintain communications in dismount Transmission power max. 50 W
operations, the system’s “jerk-and-run” capability allows the hand-
GNSS
Built-in GNSS receiver for GPS, Glonass and
Galileo systems with automatic despatch of
positional reports (PLI) on the background of
voice or data communication - G-Track system.
Co-site performance
The transceiver is manufactured with or
without a co-site filter. Integrated co-site filters
make it possible to operate multiple radios
simultaneously at close distance.
Intercom
The RF4050 provides interface for connection
to vehicle intercom systems (e.g. VICM200
Combat).
Czech Republic
Subject to change without notice.