You are on page 1of 69

Internal

Traffic Statistics Analysis

Issue 2.0 www.huawei.com

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved


Reference

 31160978-BSC Traffic Statistic


Manual Volume I
 31033203-BSS Troubleshooting
Manual

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 2


 Upon completion of this course, you will be
able to:
 Know the traffic statistics system
structure
 Understand some often-used traffic
measurement items
 Locate some problems through the
traffic statistics system

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 3


Chapter 1 Brief introduction to BSC traffic
statistics

Chapter 2 Locate problem through traffic


analysis

Chapter 3 Case study for traffic statistics

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 4


Brief Introduction to BSC Traffic Statistics Item

 TCH Congestion Rate


 TCH congestion rate (TCH overflow) = Attempted TCH
seizures meeting a TCH blocked state / Attempted TCH
seizures (all) * 100%

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 5


Brief Introduction to BSC Traffic Statistics Item

 SDCCH congestion rate (SDCCH overflow)


 SDCCH congestion rate (SDCCH overflow)= times of attempted
seizures meeting an SDCCH blocked state / attempted SDCCH
seizures (all) * 100%

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 6


Brief Introduction to BSC Traffic Statistics Item

 TCH Call Drop Rate


 TCH Call Drop Rate = TCH Call Drops / Successful TCH
Seizures (all) *100%
 SDCCH Call Drop Rate
 SDCCH Call Drop Rate = SDCCH call drops / successful
SDCCH seizures (all) *100%

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 7


Brief Introduction to BSC Traffic Statistics Item

 Handover Success Rate


 Inter cell handover success rate= (Successful incoming internal
inter cell handovers + Successful incoming interBSC inter cell
handovers + Successful outgoing internal inter cell handovers +
Successful outgoing interBSC inter cell handovers) / (Attempted
incoming internal inter cell handovers+ Attempted incoming
interBSC inter cell handovers + Attempted outgoing internal
inter cell handovers + Attempted outgoing interBSC inter cell
handovers) *100%

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 8


Brief Introduction to BSC Traffic Statistics Item

 Handover Success Rate


 Inter cell radio handover success rate= (Successful
incoming internal inter cell handovers + Successful
incoming interBSC inter cell handovers + Successful
outgoing internal inter cell handovers + Successful outgoing
interBSC inter cell handovers) / (Incoming internal inter cell
handovers + Inter BSC incoming cell handovers + Outgoing
internal inter cell handovers + Inter BSC outgoing cell
handovers) * 100%

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 9


Brief Introduction to BSC Traffic Statistics Item

 TCH interference band measurement


 The result in each TCH interference band shows the
average number of idle TCH within this interference band in
the statistic period, which reflects the average interference
level.
 In urban and suburb area, because of different density of
base station and the frequency reuse pattern, the
acceptable interference level is different.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 10


Brief Introduction to BSC Traffic Statistics Item

 Receiving level measurement


 Receiving level measurement is based on TRX.
 The receiving level is divided into 6 bands
 Band 0 : -110~-100dBm
 Band1 : -100~-95dBm
 Band 2 : -95~-90dBm
 Band 3 : -90~-80dBm
 Band 4 : -80~-70dBm
 Band 5 : > -70dBm

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 11


Chapter 1 Brief introduction to BSC traffic
statistics

Chapter 2 Locate problem through traffic


analysis

Chapter 3 Case study for traffic statistics

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 12


Traffic Statistics Analysis

General method for traffic analysis

BSC Measurement Function

High call drop rate High congestion rate Low handover success rate

SDCCH performance

Outgoing handover

Incoming handover
TCH performance

TCH performance

TCH performance

Link Balance
Link balance

Link balance
Alarm data

Alarm data

Alarm data
Call drops

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 13


Traffic Statistics Analysis

 Combine traffic statistics analysis with other optimization


method
 Drive test: simulate common subscriber’s behavior.
 Analyze objects
 Coverage
 Quality
 Handover
 Signaling
 Others

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 14


Traffic Statistics Analysis-TCH Call Drop
 TCH call drop analysis

Cell with high call drop rate

Alarm and Cell performance Call drop measurement Handover


hardware fault statistics measurement

Average uplink level at Outgoing inter cell


Call drop times
TCH call drops handover success rate

Interference Average down link level at


Incoming inter cell
band TCH call drop
handover success rate
Causes of
Average uplink quality at
call drop
TCH call drop Handover
failure and re-establish
Average downlink quality failure
at TCH call drop

Average TA value at
TCH call drop

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 15


Traffic Statistics Analysis-TCH Call Drop

 Call drop types


 Edge call drop: low receiving signaling strength, large TA.
 Short distance call drop: low receiving signal strength and
small TA.
 BQ call drop: high receiving signal strength and poor quality.
 Sudden call drop: before call drop, the call is normal then
call drop happened suddenly.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 16


Traffic Statistics Analysis-TCH Call Drop

 Edge call drop


 Causes
− MS is out of cell’s effective coverage area.
− “Island” phenomenon caused by over shooting or missing
neighbor.
− Isolated site.
 Solutions
− Add new site to guarantee the effective continuous coverage.
− Add the necessary neighbor.
− Adjust antenna height and antenna downtilt, use high gain
antenna
− Modify some parameters: “SACCH multi-frames”, “Radio link
timeout counter”, “handover threshold”, “handover statistic time”,
etc..

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 17


Traffic Statistics Analysis-TCH Call Drop

 Short distance call drop


 Causes
− Poor coverage caused by complicated terrain or high
dense building.
 Solutions
− Increase EIRP.
− Adjust antenna direction and downtilt, make the main
lobe point to high traffic area.
− Adjust parameters related to call drop.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 18


Traffic Statistics Analysis-TCH Call Drop

 BQ call drop( high signal strength)


 Causes
− High transmission bit error rate (BER).
− Uplink or downlink interference.
▪ Interference caused by repeater.
▪ Interference caused by radar or other similar
equipment.
▪ Interference caused by improper frequency planning.
▪ Self-interference caused by BTS.
 Solutions
− Try to find the external interference source.
− Optimize frequency planning.
− Adjust antenna system, avoid “island”.
− Solve the problem of transmission quality.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 19


Traffic Statistics Analysis-TCH Call Drop

 Overall process for call drop analysis


 Find out cells with high call drop rate.
 Classify the call drop according to the character.
 Analyze the cells’ traffic load and total call drop times.
 Analyze the call drop measurement function.
 Check the interference band.

 First of all, we shall know the type of the call drop.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 20


Traffic Statistics Analysis-TCH Call Drop

 The main causes for call drop


 Interference (internal and external).
 Poor coverage (coverage hole and island).
 Improper handover (neighbor planning and handover
parameter setting).
 Unbalanced up-down link (TMA, power amplifier, antenna
direction).
 Improper parameter settings ( RLT and SACCH multi-
frames).
 Equipment problem (TRX, power amplifier, and TMA).

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 21


Traffic Statistics Analysis-TCH Call Drop
 Interference analysis process
 Analyze the appearance period of the interference.
 Block TRX in turn and monitor the interference
measurement results.
 Calculate the handover caused by poor quality and check
the average receiving quality level for each TRX.
 In call drop measurement function, check the average
signal strength and quality of call drops.
 Through drive test, check the interference and signal quality.
 Use spectrum analyzer to find the interference source.
 Dispose equipment fault (such as: TRX self-oscillation,
antenna inter-modulation).
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 22
Traffic Statistics Analysis-TCH Call Drop
 Coverage problem analysis
 Traffic items
− In power control measurement function, the average uplink or
downlink signal strength is too low.
− In receiving level measurement function, a lot of low signal
strength records can be found.
− In inter-cell handover measurement function, the average
receiving signal strength is too low when handover is triggered.
− In call drop measurement, the signal strength is too low when call
drop happens, or the TA value is abnormal.
− In undefined adjacent cell measurement function, the potential
neighbor cells with high average signal strength can be find.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 23


Traffic Statistics Analysis-TCH Call Drop
 Coverage problem analysis
 Judgment method
− In Power Control measurement
▪ Check whether the average distance between MS and
BTS comply with design.
▪ Check whether the maximum distance between MS and
BTS is abnormal in several continuous periods.
− In outgoing inter-cell handover measurement function
▪ check whether the handover successful rate to some cells
is low.
▪ check the number of unsuccessful handover with
unsuccessful reversion (call drop caused by handover).

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 24


Traffic Statistics Analysis-TCH Call Drop

 Coverage problem analysis


 Disposing method
− Drive test in the suspected poor coverage area.
− Adjust the following parameters based on the drive test
results
▪ BTS transmitting power
▪ Antenna downtilt and height
▪ RXLEVEL_ACCESS_MIN
− Add site to ensure the continuous coverage.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 25


Traffic Statistics Analysis-TCH Call Drop

 Improper handover (neighbor planning and handover


parameters)
 Disposing method
− Check the handover parameters to see whether there
are improper parameter settings.
− In inter-cell handover measurement function, check
whether there are many unsuccessful outgoing cell
handovers with unsuccessful reversions.
− In undefined adjacent cell measurement function, check
whether the signal strength and the number of
measurement reports for the undefined neighbor cell are
high.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 26


Traffic Statistics Analysis-TCH Call Drop

 Imbalanced up-down link (tower amplifier, power amplifier, and


antenna directions)
 Disposing method
− Analyze “up-down link balance measurement function”
statistics result and confirm whether the uplink and
downlink are balanced.
− In call drop measurement function, analyze the average
receiving signal strength and quality for both the uplink
and downlink.
− In power control measurement function, analyze the
average receiving signal strength for both the uplink and
downlink.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 27


Traffic Statistics Analysis-TCH Call Drop

Balance between uplink and downlink Link balance rank Range of D

Let D= (downlink receiving level − 1 ≤ -15


uplink receiving level) − (MS
2 -14 ~ -10
sensitivity − BTS sensitivity).
Usually the MS sensitivity is - 3 -9 ~ -6
102 dBm and the BTS sensitivity is - 4 -5 ~ -3
108dBm. The formula can be
simplified as 5 -2 ~ 0
− D= downlink receiving level − 6 0
uplink receiving level – 6dB
7 1~2
If D=0, it means uplink and
downlink are balanced 8 3~5
If D>0, it means downlink is better 9 6~9
than uplink
If D<0, it means uplink is better 10 10 ~ 14
than downlink 11 ≥15

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 28


Traffic Statistics Analysis-TCH Call Drop

 Improper radio parameter setting (Radio Link timeout, SACCH


multi-frames)
 Judgment method
− In system information data, check the radio link timeout
− In cell property data, check SACCH multi-frames, and
the timer for radio link connection (T3105).

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 29


Traffic Statistics Analysis-TCH Call Drop
 Equipment problem (TRX, power amplifier, tower amplifier, etc.)
 Judgment method
− In TCH measure function, many TCH seizure failures due to A
interface problem.
− In call drop measurement function, there are many call drops due to
ground links.
− In TCH measurement function, there are many TCH seizure failures
due to equipment failure.
 Disposing method
− Monitor transmission and board alarms (FTC board failure, A
interface PCM synchronization alarm, LAPD link disconnected,
TRX alarm); analyze whether transmission is disconnected or some
boards are faulty.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 30


Traffic Statistics Analysis-SDCCH Call Drop

SDCCH call drop

Refer to TCH call drop analysis.

The cause and mechanism of SDCCH call drop


are almost the same as TCH.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 31


Traffic Statistics Analysis-Handover
Handover analysis

Low Handover Success Rate

Alarm (Clock), Handover Measurement


Hardware Fault Function TCH Measurement Function

Incoming Inter Cell Outgoing Inter Cell Failure Cause of Failure in BSC
Failure

Incoming Inter cell Outgoing Inter cell 1.Illegal Channels


Handover Handover 2.Illegal Carrier
Measurement Function Measurement Function 3.Illegal TA
4.Timer out
5.No available channel
6.Others

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 32


Traffic Statistics Analysis-Handover

 Handover failure analysis


 Causes of handover failure
− Improper handover parameters.
− Hardware fault (TRX board fault).
− Congestion
− Interference
− Coverage
− Clock fault (Internal clock, external clock)

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 33


Traffic Statistics Analysis-Handover

 Handover failure analysis


 Disposing method
− Find out the cells with low handover success rate.
− Find the out the cells with high handover failures.
− Compare the incoming cell handover failures and
outgoing cell handover failures.
− Register the task to measure the incoming cell handover
and outgoing cell handover.
− Find out handover failure relation (failure to all the
neighbor cells or part of the neighbor cells).

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 34


Traffic Statistics Analysis-Handover
 Improper parameter settings
 Disposing method
− Check whether the handover threshold such as TA, BQ and
handover function switch are suitable or not.
− Check whether the successful TCH seizures for handover are
much more than successful TCH seizures for call. If handover
times divided by call times is larger than 3, then it indicates that
there may be ping-pong handover. Check the parameter settings
and adjust them (layer setting, layer handover hysteresis, inter
cell handover hysteresis, PBGT threshold, etc.).
− Check whether the average signal strength is low when the
handover happens. If so, it indicates the edge handover threshold
is too low.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 35


Traffic Statistics Analysis-Handover

 Hardware fault
 Problem description
− The target cell has idle channels but when applying for the
channels CH_ACT_NACK or TIMEOUT message appears.
− TCH availability is abnormal.
− If the call drop rate and congestion rate are both high, the
equipment may have some fault.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 36


Traffic Statistics Analysis-Handover

 Hardware fault
 Disposing process
− Monitor transmission and board alarms (FTC board failure, A
interface PCM sync alarm, LAPD link disconnected, TRX
alarm).
− Analyze whether the transmission is disconnected or the
boards have some fault (for example: the TRX is damaged).
− Check whether there is clock alarm.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 37


Traffic Statistics Analysis-Handover

 Congestion
 Objects needed to be analyzed
− Cells with low incoming handover success rate.
− Neighbor of the cell with low incoming handover success rate.
 Locating the problem
− In incoming inter cell handover measurement function, check
whether many handover failures are caused by congestion.
− For low incoming handover success rate, check the cell’s traffic .
− For low outgoing handover success rate, check the neighbor
cell’s traffic.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 38


Traffic Statistics Analysis-Handover

 Congestion
 Disposing process
− Adjust the cell’s coverage (adjust BTS transmitting
power, RXLEVEL_ACCESS_MIN, RACH access
threshold, and the antenna downtilt and height).
− Adjust parameters (CRO, load handover parameters,
cell priority and handover parameters).
− Expand or adjust TRX configuration between high and
low traffic cells.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 39


Question
The item “radio handover success rate” is the ratio of successful
handovers to handovers. The handovers are counted when sending
or receiving HO_CMD or HO_REQ_RSP in the handover process.
Please write down the possible reasons that can cause the low radio
handover success rate between BSCs.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 40


Answer

 There are two kinds of outgoing handovers. One is intra-BSC


handover, and the other is inter-BSC handover.
 The possible reasons are list as following. For inter-BSC handover:
 If the uplink signal strength of the target cell is low, the MS cannot
access the target cell. Thus the handover fails
 If the target cell is a wrong cell which has the same BCCH and
BSIC as the expected target cell, MS will send access request to a
wrong cell. Then MS cannot access. Thus the handover fails.
 If the CGI is wrong, MSC will send the handover request with wrong
CGI. Then MS will send access request to a wrong cell. It has the
same effect as the above one.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 41


Traffic Statistics Analysis-TCH Congestion

 TCH congestion
 Main causes
− Insufficient system capacity
− Interference
− Coverage
− Antenna and feeder problems
− Improper parameter setting (system information
parameters)

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 42


Traffic Statistics Analysis-TCH Congestion

 Insufficient system capacity or traffic imbalanced

 Judgment method

− The traffic is high and is imbalanced between cells.

− There are many channel request rejections due to channel busy.

− Incoming handover measurement shows that there are too many


unsuccessful incoming cell handovers (congestion).

 Disposing process

− Expand or adjust the configuration between high and low traffic cells

− Adjust coverage (adjust BTS transmitting power, antenna direction,


downtilt, height, etc.).

− Adjust parameters (CRO, Rx_Lev_Access_Min, load handover parameters,


cell priorities, handover parameters).

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 43


Traffic Statistics Analysis-TCH Congestion
 Interference (external and internal interference)
 Problem description
− Interference brings unacceptable BER which affects the
assignment process.
− Downlink Interference makes MS’s DSC decrease to 0, then
MS reselects to another cell with low signal strength, and this is
a potential reason for TCH seizure failure.
− If TCH seizure failures (including handover) minus attempted
TCH seizures meeting TCH overflow is large, then there may
be some interference.
 Disposing process
− Refer to TCH call drop caused by interference.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 44


Traffic Statistics Analysis-TCH Congestion

 Antenna and feeder problem


 Disposing process
− In cell frequency scan measurement function, check the
measurement results got from main receiving antenna
and diversity receiving antenna.
− In Up-down link balance measurement function, check
the measurement report numbers in each rank.
− Check antenna direction, downtilt and connection.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 45


Traffic Statistics Analysis-TCH Congestion

 Improper parameter settings


 Check the relevant parameters such as
RXLEV_ACCESS_MIN, CRO, BTS transmitting power,
handover threshold etc..

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 46


Traffic Statistics Analysis-TCH Congestion

 Coverage
 Refer to coverage analysis for TCH call drop rate.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 47


Traffic Statistics Analysis-SDCCH Congestion

 SDCCH congestion
 Main causes
− Improper parameter settings (system information)
− Insufficient system capacity
− Improper LAC planning
− Interference

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 48


Traffic Statistics Analysis-SDCCH Congestion

 Improper parameter settings

 Judgment method
− Successful immediate assignments / immediate assignment
transmissions >85%.
− The above formula shows the ratio between number of EST_IND
messages that MS sends to BSC and the immediate assignment
commands that BSC sends to BTS. It indicate whether there are some
improper parameters in the system information.
 Disposing process
− Adjust the access parameters (Random access error threshold, RACH
minimum access level, MS Max Retrans, Tx-integer).
− Adjust the location update related parameters (dual-band network
parameters such as CRO, cell reselection hysteresis, T3212).

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 49


Traffic Statistics Analysis-SDCCH Congestion

 Insufficient system capacity


 Problem description
− Many location updates happen at the border of different
location areas.
− Massive location updates happen simultaneously.
 Disposing method
− Properly plan the location area
− Configure more SDCCHs
− Use SDCCH dynamic allocation
− Add more TRX

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 50


Traffic Statistics Analysis-SDCCH Congestion

 Improper LAC planning


 The border of different location area is the street.
 The border of different location area is at the high traffic
area.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 51


Traffic Statistics Analysis-SDCCH Congestion

 Interference
 Problem description
− RACH minimum access level is low.
− Interference in the system, which will bring a lot of illusory
SDCCH channel requests.
 Disposing process
− Properly set the RACH minimum access level
− Eliminate the interference

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 52


Chapter 1 Brief introduction to BSC traffic
statistics

Chapter2 Locate problem through traffic


analysis

Chapter 3 Case study for traffic statistics

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 53


Case Study-One (Handover)

 Problem description
 Handover success rate is always very low because of the
congestion (about 70%)
 In the evening of 3rd. Dec, site D located in urban is
expanded from “S2/2/2” to “S3/3/3”. The busy hour
handover success rate does not get improved after
expansion. Sometimes handover success rate is lower than
before. At the same time, lots of subscribers complain
about the network quality.
 Refer to busy hour traffic statistics of 3rd. Dec.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 54


Case Study-One (Handover)
Traffic statistics for 24th.Nov
Intra-BSC Intra-BSC
Handover Radio handover incoming handover incoming TCH
Cell failures handover
success rate success rate failures congestion
(no channel available) (others)
D_1 53.41% 90.02% 397 18 47.53%
D_2 49.82% 93.98% 389 2 67.23%
D_3 57.67% 90.06% 314 51 48.31%
C_3 61.25% 91.67% 502 25 40.61%
A_2 78.40% 89.07% 0 33 0
A_3 77.14% 93.80% 0 20 0
F_2 76.36% 76.36% 0 12 0
E_1 66.22% 88.10% 26 63 5.33%
E_2 92.73% 94.44% 0 2 0
E_3 83.25% 91.91% 0 6 0
B_3 83.48% 95.53% 0 5 0.75%
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 55
Case Study-One (Handover)
Traffic statistics for 13th.Dec
Intra-BSC Intra-BSC
Handover Radio handover incoming handover incoming TCH
Cell failures handover
success rate success rate failures congestion
(no channel available) (others)
D_1 49.75% 52.95% 17 246 5.27%
D_2 56.48% 58.56% 1 161 0.58%
D_3 65.92% 66.08% 0 86 22.37%
C_3 60.58% 66.3% 113 166 0.00%
A_2 70.55% 71.71% 0 0 1.06%
A_3 68.02% 68.95% 0 0 0.00%
F_2 60.61% 60.61% 0 13 0.56%
E_1 63% 64.08% 1 55 0.00%
E_2 61.77% 62.69% 0 20 0.00%
E_3 50.3% 50.3% 0 0 0.00%
B_3 78.60% 82.45% 0 11 0.34%
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 56
Case Study-One (Handover)
Site location

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 57


Case Study-One (Handover)

 Analysis
 Analyzing the traffic statistics before expansion and after
expansion, we find that before the expansion the handover
failure is caused by congestion and the radio handover
success rate is normal. In Urban area many cells’ radio
handover success rate decreased after expansion, therefore
we conclude that the cause of handover failure after
expansion has been changed.
 Analyzing the urban site location diagram, we find lots of cells’
radio handover success rate are low and these cells have
handover relationship with site D. Therefore we can suspect
that the handover problem may be caused by site D.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 58


Case Study-One (Handover)

 Analysis
 After checking the hardware of site D through maintenance
console, we find the state of TMU board is abnormal and
clock is unstable. Finally we affirm the low handover
success rate is caused by the wrong setting of switches in
TMU board. For sure, the high call drop rate is caused by
handover failures.
 The day after processing, the busy hour handover success
rate is higher than 90%. Thus the problem is solved.
 Refer to busy hour traffic statistics of 17th. Dec.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 59


Case Study-One (Handover)
Traffic statistics for 17th.Dec
Intra-BSC Intra-BSC
Handover Radio handover incoming handover incoming TCH
Cell failures handover
success rate success rate failures congestion
(no channel available) (others)
D_1 86.58% 95.90% 47 10 13.00%

D_2 93.09% 96.88% 10 15 3.40%

D_3 95.57% 96.79% 0 10 0.00%

C_3 86.84% 95.94% 80 7 18.26%

A_2 88.43% 91.51% 1 21 0.48%

A_3 92.56% 94.12% 0 6 0.00%

F_2 98.47% 89.47% 0 1 0.00%

E_1 93.69% 95.59% 1 6 1.44%

E_2 93.55% 93.55% 0 2 0.00%

E_3 97.40% 97.45% 0 1 0.00%

B_3 91.80% 96.89% 10 1 7.92%

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 60


Case Study-One (Handover)

 Conclusion and suggestion


 Pay attention to the difference between radio handover
success rate and handover success rate because it can
help us to locate handover problem efficiently.
 Handover problem sometimes is accompanied with call
drops and others; it is an important clew for locating and
solving problems.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 61


Case Study-Two (Call drop)

 Fault description
 When we analyze the traffic statistics, we find that a cell’s
call drop rate in busy hour is large than 2%.
 In cell call drop measurement function, we find that the
average uplink level of call drop is 1 (-109dBm), while the
downlink level is 26 (-84dbm). High call drop rate is caused
by imbalance between uplink and downlink.
 In up-down link balance measurement function: we find one
TRX is normal, but there may be some problem with the
other one. Result of rank 1 is 0, while that of rank 11 is
5833. It means the downlink is better than uplink.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 62


Case Study-Two (Call drop)

 Analysis
 We can exclude the problem of antenna and feeder
because only one of the two TRXs is abnormal. Therefore
we think that the problem may be caused by the uplink
channel of TRX or CDU.
 After we change the CDU, the problem is solved.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 63


Case Study-Two (Call drop)

 Conclusion and suggestion


 To find the cause of call drop, we should register the following
useful traffic statistics:
− TCH measurement function
− Call drop measurement function
− Inter cell handover measurement function
− Up-down link balance measurement function
 By analyzing the result of the above traffic statistics, we can
locate the cause of the call drop (handover, interference,
coverage etc.) and then register more detailed traffic
measurement tasks.
 DT also is a effective method to find call drop problem.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 64


Case Study-three (SDCCH congestion)

 Fault description
 In the network, the radio link connection success rate is low.
After analyzing the traffic statistics, we find that it caused by
SDCCH congestion and the congestion only exists in a few
sites.
 Analyzing traffic statistics we find that in the congested cell,
attempted SDCCH seizures are from 300 to 400 in a
certain hour. The configuration of all the related BTSs is
S1/1/1. Each cell has one SDCCH/8 channel. Normally, it
can deal with 300-400 SDCCH seizures. But it is very
strange that there are dozens of SDCCH congestions in
busy hour.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 65


Case Study-three (SDCCH congestion)
 Analysis
 Register “SDCCH measurement function” and analyze the result. We
find that most of the SDCCH seizures are used for location update.
After we analyze the site distribution, we find that the congested BTSs
are located at the border of two location areas along the railway. So we
can conclude that SDCCH congestion shall be caused by massive
location updates.
 In SDCCH measurement function, we find that most of the location
update happened in a specific 5 minutes. After checking the train
timetable, we find that 4 or 5 trains passed by in this period. When the
trains pass by, a large amount of location updates happen
simultaneously.
 After adding more fixed SDCCHs and switching on “Dynamic SDCCH
allocation” function, the problem is solved.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 66


Case Study-three (SDCCH blocking)

 Conclusion and suggestion


 For SDCCH congestion, firstly we should register SDCCH
measurement function, and then analyze the traffic
statistics to find the cause of the problem (Location update,
SDCCH handover, call setup etc.).
 Then check the parameter settings, interference, location
area planning etc., to do further analysis.
 Adding SDCCH channels or enabling dynamic SDCCH
allocation function can solve the congestion caused by
insufficient capacity.
 Set the parameter and plan the location area properly to
decrease the SDCCH congestion.

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 67


Summary

Summary  Traffic statistics system basics


 Key traffic measurement items
 Traffic statistics analysis method
 Some cases

HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 68


Thank You
www.huawei.com

You might also like