ASME Unground 595 Slabs with no grinding. Ground 596 Slabs with grinding. Hot rolled (not heat treated, not descaled). HR 599 1U a1 Suitable for products which are to be further worked (e.g. re-rolling). Hot rolled and heat treated (not descaled). HRA 504 1C Ic Suitable for industrial heat resisting and materials handling applications. HRP 503 Hot rolled and pickled (not heat treated). Hot rolled, heat treated and descaled. Suitable No. 1 501 No. 1 1D IIa when smoothness and uniformity of finish are not important. Cold rolled, heat treated and pickled, bright 2B 522 No. 2B 2B IIIc finish (obtained by skin passing or tension levelling). Cold rolled, heat treated and pickled, dull 2D 512 No. 2D 2D IIIb finish. Suitable for forming applications. A linearly textured polished finish, one or both No. 3 531 No. 3 2J IV sides, with a typical surface roughness (Ra) of about 1.75µm. 543 (G180) No. 4 2J IV A linearly textured polished finish, one or 545 (G220) No. 4 2J IV both sides, with a typical surface roughness (Ra) of about 0.6µm. 546 (G240) No. 4 2J IV No. 4 547 (G320) No. 4 2J IV 548 (G400) No. 4 2J IV 523 2G IV Soft satin polished finish, one or both sides, with a transverse Ra <0.5µm. SB 551 No. 6 2K IV Bright Cold rolled, bright annealed finish, retained by BA 571 Annealed 2R IIId final annealing in a controlled atmosphere Finish furnace (may be skin passed). Columbus hollowware finish for improved drawability and polishability – cold rolled bright annealed finish, retained by final annealing in a controlled atmosphere HOL 511 furnace.